Professional Documents
Culture Documents
Aces Objectives 4 EE
Aces Objectives 4 EE
a.Millman's theorem
b.Compensation theorem
c.Superposition theorem
d.Reciprocity theorem
2.The theorem wherein a circuit is replaced by a single voltage source and series impedance
is,
a.Thevenin's
b.Maxwell's
c.Kirchoff's
d.Norton's
a.low dc voltage
b.high ac voltage
c.low ac voltage
d. high dc voltage
a. 3600
b.860
c.3413
d.778
5.When the length of.wire is doubled and all other factors remained the same, what would
the wire resistance be?
a.decreased
b.doubled
c.remained the same
d.can not be determined
6. In de moors, carbon brushes are preferred thán copper brushes due to which ofthe
following reasons?
a.fault current
b.fault MVA
c.fauit power factor
d.fault voltage
8. As per RA 9136 which is known as Electric Power Industry Reform Act of 2001,SAIFI
ineans,
9.What is the type of communication that only one of the two parties can transmit at
a. time.
a.full duplex
b.half duplex
c.simplex
d.bicomm
a.24
b.28
c.16
d.18
a.1800
b.1000
c.3000
d.1500
a.600
b.250
c.300
d.500
13. Electrodes of rods of iron or steel shall be at least..
_mm in diameter.
a.13
b.16
c.20
d.6
14.At least
mm of free conductor, measured from the point in the box where it emerges from its raceway
shall be left at each outlet, junction and switch point for
splices or connection to fixtures or devices.
a.150
b.250
c.300
d.500
15. Each motor compressor shall have an overload protection set at not more than.
% of the motor compressor rated load current.
a.130
b.140
c.175
d.125
a.21
b.51
c.50
d.87
17. As per R.A 9136 which is known as Electric Power Industry Reform Act of 2001,a large
customer has a demand of at least
MW.
a.1
b.15
c.10
d.5
18. As per RA 9136 which is known as Electric. Power Industry Reform Act of 2001, a
generator is classified as large generator if its capacity is in excess of
MW.
a.10
b.15
c.20
d.25
19. As per RA 9136 which is known as Electric Power Industry Reform Act of 2001, a
voltage level exceeding 1kV up to 34.5kV is classified as,
a.low voltage
b.medium voltage
c. high voltage
d.extra high voltage
a. 115
b.125
c.135
d.175
24.When the relative permeability of a material is slightly less than one, then the material is
called.
a.diamagnetic
b.ferromagnetic
c.paramagnetic
d.none of these
25. It is the ratio of total number of sustained customers power interruption within given
period to the total number of customers served within the same period.
a.SAIFI
b.SAIDI
c.MAIFI
d.WAIFI
a.1.11
b.1.414
c.1.21
d.1.14
27. The type of ac distribution system commonly used to supply both light and power is the,
29.The power is to be measured for a.balanced delta connected load whose terminals can
not be opened. How many watt meters do you need?
a.3
b.1
c.2
d.4
30. Two watt meters can be used to measure 3φ power for &,