Professional Documents
Culture Documents
Pull Push Rule
Pull Push Rule
This study source was downloaded by 100000797165521 from CourseHero.com on 11-18-2022 15:34:51 GMT -06:00
https://www.coursehero.com/file/62540442/Pull-Push-Ruledocx/
Ruler
A ruler, sometimes called a rule or line gauge, is an
instrument used in geometry, technical drawing, printing as well
as engineering and building to measure distances or to rule
straight lines. The ruler is a straightedge which may also contain
calibrated lines to measure distances.
A ruler, sometimes called a rule or line gauge, is an
instrument used in geometry, technical drawing, printing
as well as engineering and building to measure.
This study source was downloaded by 100000797165521 from CourseHero.com on 11-18-2022 15:34:51 GMT -06:00
https://www.coursehero.com/file/62540442/Pull-Push-Ruledocx/
Meter stick
A rule one meter long (usually marked of in centimeters and
millimeters).
This study source was downloaded by 100000797165521 from CourseHero.com on 11-18-2022 15:34:51 GMT -06:00
https://www.coursehero.com/file/62540442/Pull-Push-Ruledocx/
Try Square
A try square is a woodworking or a metal working tool used
for marking and measuring a piece of wood. The square refers to
the tool's primary use of measuring the accuracy of a right angle
(90 degrees); to try a surface is to check its straightness or
correspondence to an adjoining surface. A piece of wood that is
rectangular, flat, and has all edges (faces, sides, and ends) 90
degrees is called four square. A board is often milled four square
in preparation for using it in building furniture.
This study source was downloaded by 100000797165521 from CourseHero.com on 11-18-2022 15:34:51 GMT -06:00
https://www.coursehero.com/file/62540442/Pull-Push-Ruledocx/
Caliper
A caliper (British spelling also calliper, or in plurale tantum sense a
pair of calipers) is a device used to measure the distance between two
opposite sides of an object. A caliper can be as simple as a compass with
inward or outward-facing points. The tips of the caliper are adjusted to fit
across the points to be measured, the caliper is then removed and the
distance read by measuring between the tips with a measuring tool, such as
a ruler.
This study source was downloaded by 100000797165521 from CourseHero.com on 11-18-2022 15:34:51 GMT -06:00
https://www.coursehero.com/file/62540442/Pull-Push-Ruledocx/