Professional Documents
Culture Documents
(70220042) SRP-2309-50CCT Instruction
(70220042) SRP-2309-50CCT Instruction
PUSH DIM
DA
L DA
CW-
CH 2:CW output(-) -40℃ ~ +80℃, 10% ~ 95% RH
DA N DA WW-
CH 1:WW output(-) & Humidity
DALI LED Driver
AC INPUT
0-6 0-9
NC
NC
Safety Standards ENEC EN61347-1, EN61347-2-13 approved
NC
1 2 3 4 5 6 7 8
Withstand Voltage I/P-O/P: 3.75KVAC
Safety & Isolation Resistance I/P-O/P: 100M Ohms / 500VDC / 25℃ / 70% RH
Dips to set the operation current
AC 200-240V input EMC
Product Data EN55015, EN61000-3-2, EN61000-3-3
EMC Emission
LED Channel 2 EMC Immunity EN61547, EN61000-4-2,3,4,5,6,8,11
Selectable Current 250mA 300mA 350mA 400mA 450mA 500mA 600mA 700mA
191300H, MIL-HDBK-217F @ 230VAC at full load and 25℃
MTBF
DC Voltage Range 8-48V 8-48V 8-48V 8-48V 8-48V 8-48V 8-48V 8-48V ambient temperature
Others
Output Selectable Current 800mA 900mA 1000mA 1100mA 1200mA 1300mA 1400mA 1500mA Dimension 210*50*32mm (L*W*H)
DC Voltage Range 8-48V 8-48V 8-48V 8-46V 8-41V 8-38V 8-35V 8-33V
DALI INPUT
L DA L DA CW-
desired DALI address appears. Click first button to set “tens” position and second button to set N
DA N DA
AC INPUT
NC
0-6 0-9
NC
2.3.Then press and hold down any of the 2 buttons until the numeric digital display stops flashing 1 2 3 4 5 6 7 8
NC
address is assigned for the dimmer, and the display shows . Setting DALI address as AC Power
50/60Hz
50.0
Note: The digital display will show When the DALI master is assigning addresses.
4.Once an address is selected, all two channels' address will be the same. For example, if the dimmer is
addressed to 22 on the display then CH1 and CH2 will be the same address 22.
32.0
While connected with a AC PUSH, the digital display will show “PD” which means Push Dimmer Mode,
operations under Push Dimmer Mode are as follows:
5.1. Click the button to switch ON/OFF
5.2. Press and hold down the button to increase or decrease light intensity to desired level and release it, then 210.0
repeat the operation to adjust light intensity to opposite direction. The dimming range is from 0.1% to 100%.
5.3. Memory function after power off or power failure enables the device to memorize the status before power
off while power on again.
Wiring Diagram
PUSH DIM
DA
DALI INPUT
L DA
DA CW-
DALI bus DA
N DA
WW-
DA
DALI LED Driver
AC INPUT
NC
0-6 0-9
NC
NC
1 2 3 4 5 6 7 8
AC Power
50/60Hz