Smart Night Lamp

When touching the Me touch sensor of the night lamp, the night lamp is turned
on, and its brightness can be adjusted by rotating the Me potentiometer. Then
touching the touch sensor of the night lamp again, the night lamp goes out.

Point of knowledge learned:

Principle and Application of Me Potentiometer
Module, Me Touch Sensor and Me RGB LED.
Learn more:
Me Potentiometer: https://www.makeblock.com/
project/me-potentiometer
Me Touch Sensorhttps: https://www.makeblock.com/
project/me-touch-sensor
 Parts list

1 SKU:13400 2 SKU:13604 3 SKU:11020 4 SKU:60715 5 SKU:61400

Note: Please take the screwdriver from mBot educational kit 6 SKU:60006 7 SKU:70552 8 SKU:71004 9 SKU:14202 10 SKU:70018

1 Me RGB LED × 1 6 Slide Beam 016 × 2

2 Me Potentiometer × 1 7 M4*8 Screw × 50

3 Me Touch Sensor × 1 8 Nylon Lock Nut M4 × 50

4 Beam 0412-140 × 4 9 RJ25 Cable - 20cm × 4
5 Plate 45° × 2 10 Wrench 5mm&7mm × 1
Construction Steps

Step 1 Step 2
Install the Me touch sensor on the left arm of Install the single-hole beam 140 on the right
the mBot. arm of the mBot.

Note: Adult supervision is required when the screwdriver is used

Construction Steps

Step 3 Step 4
Screw another M4 screw at the end of the Install a 45° plate at the other end of the
single-hole beam 140. single-hole beam.
Construction Steps

Step 5 Step 6
Install the double-hole beam 032 on Install the Me RGB LED on the double-hole
the plate. beam.
Construction Steps

Step 7 Step 8
Install the Me Potentiometer to the rear Install the Me RGB LED on the double-hole
of mBot. beam.
Construction Steps

Completed!
Wiring diagram

Me Potentiometer

Ultrasonic sensor

Me RGB LED

Me touch sensor
Project program
LED Lamp Smart mBot Panel Rear Wing mBot Temperature and Humidity
Detector mBot

Voice-controlled mBot Smart Night Lamp mBot Mini-gripper mBot

Makeblock Co., Ltd

Phone: +86 (0)755-26392228
Address: 3rd Floor, Building C3, Nanshan iPark, No.1001 Xueyuan Avenue,
Nanshan District, Shenzhen, Guangdong Province, China