You are on page 1of 5

2014 Jeep Compass Limited

2014 TRANSMISSION Transmission - Non-DTC Based Diagnostics - Compass & Patriot

2014 TRANSMISSION

Transmission - Non-DTC Based Diagnostics - Compass & Patriot

DIAGNOSIS AND TESTING


DIAGNOSIS AND TESTING - SHIFT INTERLOCK SYSTEM

Fig. 1: Ignition Key/Switch Positions


Courtesy of CHRYSLER GROUP, LLC

1 - LOCK
2 - ACC
3 - ON
4 - START

If the shifter cannot be shifted out of Park or can be shifted out of Park without
depressing the brake pedal, follow diagnostics procedure below.

Final Verification Testing:

ACTION EXPECTED RESPONSE


1. With the Key removed, try to shift 1. Shifter CANNOT be shifted out of
out of "PARK". "PARK".
2. Insert the Key into the WIN and 2. Shifter CANNOT be shifted out of
leave it at "LOCK." Try to move the "PARK".
shifter out of "Park".

Tuesday, July 12, 2016 10:49:29


10:49:27 AM Page 1
2014 Jeep Compass Limited
2014 TRANSMISSION Transmission - Non-DTC Based Diagnostics - Compass & Patriot

3. Turn the Key to the "ON" 3. Shifter CANNOT be shifted out of


position, with foot off of brake "PARK".
pedal.
4. Turn the Key to the "ON" position 4. Shifter CAN be shifted out of
and depress the brake pedal. "PARK".
5. Leave shifter in any gear other 5. Key CANNOT fully return to
than "PARK" and try to return the "LOCK" and cannot be removed.
Key to the "LOCK" position.
6. Return the shifter to "PARK" and 6. Key CAN be removed.
try to remove the Key.
DIAGNOSTIC TEST

1. CHECK FOR DIAGNOSTIC TROUBLE CODES (DTC)


1. Engage the parking brake.
2. Connect the Wi-Tech scan tool to the vehicle.
3. Check the PCM (Powertrain Control Module) and the ABS (Antilock
Brake System) for any Brake Switch related Diagnostic Trouble Codes
(DTCs).

Are there any Brake Switch related DTCs?

Yes
Refer to the appropriate engine or brake system and perform the
appropriate diagnostic procedure(s).

No
Go To 2
2. BRAKE SWITCH
1. With the scan tool select "PCM Module" and "Data Display". Read the
Brake Switch state.
2. Check for change of state by pushing and releasing the brake pedal.

Does the brake switch change states when the pedal is pushed and
released?

Yes

Tuesday, July 12, 2016 10:49:27 AM Page 2


2014 Jeep Compass Limited
2014 TRANSMISSION Transmission - Non-DTC Based Diagnostics - Compass & Patriot

Go To 3

No
Trace and repair the Brake Switch circuit(s) as necessary.
Perform the BODY VERIFICATION TEST. Refer to
STANDARD PROCEDURE .
3. BRAKE TRANSMISSION SHIFT INTERLOCK (BTSI) TEST
1. Turn the ignition off.
2. Remove the necessary parts of the center console to visually see the
BTSI Lever on the shifter.
3. Turn the ignition on.
4. While observing the BTSI Lever on the shifter, push and release the
brake pedal several times.
Did the BTSI Lever move when the brake pedal was pushed and
released?

Yes
Refer to DIAGNOSIS AND TESTING and check for mechanical
shifter issues.

No
Go To 4
4. BRAKE TRANSMISSION SHIFT INTERLOCK (BTSI) CIRCUIT
TEST

Tuesday, July 12, 2016 10:49:27 AM Page 3


2014 Jeep Compass Limited
2014 TRANSMISSION Transmission - Non-DTC Based Diagnostics - Compass & Patriot

Fig. 2: Checking For Open Ground Or Open Brake Transmission Shift


Interlock Solenoid Unlock Circuits
Courtesy of CHRYSLER GROUP, LLC
1. Turn the ignition off.
2. Disconnect the BTSI connector on the shifter.

NOTE: The graphic shows the JS connector. Refer to the


appropriate Wiring Information for other vehicles.

3. Connect a 12 volt test light between the (Z) Ground and the (K321)
Brake Transmission Shift Interlock Solenoid Unlock circuits.
4. Turn the ignition on.
5. While observing the test light, push and release the brake pedal.

Tuesday, July 12, 2016 10:49:27 AM Page 4


2014 Jeep Compass Limited
2014 TRANSMISSION Transmission - Non-DTC Based Diagnostics - Compass & Patriot

Does the test light illuminate brightly when the brake pedal is pushed?

Yes
Replace the shifter in accordance with the Service Information.
Perform the Final Verification Test.

No
Trace and repair the open (Z) Ground or the Open (K321) Brake
Transmission Shift Interlock Solenoid Unlock circuits as
necessary.
Perform the Final Verification Test.

Tuesday, July 12, 2016 10:49:27 AM Page 5

You might also like