Professional Documents
Culture Documents
Marks Obtained
Group Member Group Member Group Member
1 2 3
NAME
REGISTRATION #
LAB REPORT
PERFORMANCE
TOTAL MARKS
________________________________________________________________________
Experiment # 05 Page 1 of 5
Electronic Circuit Design Lab
_________________________________________________________________________
PURPOSE
To study amplifiers using Op-amps..
READING
1. Chapter 12 of Floyd (textbook)
OBJECTIVE
I. To simulate an inverting op-amp amplifier
II. To simulate a non-inverting op-amp amplifier
III. To build and test an inverting op-amp amplifier
IV. To build and test a non-inverting op-amp amplifier
V. To build and test a unity buffer
REQUIRED EQUIPMENT
________________________________________________________________________
Experiment # 05 Page 2 of 5
Electronic Circuit Design Lab
_________________________________________________________________________
EXPERIMENT PROCEDURE
I. To simulate an inverting op-amp amplifier
In Multisim, simulate an inverting amplifier circuit as shown below. If your component
values differ slightly, report the exact value used in your report.
Calculate the gain of your amplifier. What does the negative sign in the
gain mean?
Show the input and output signals in your report.
Measure and report the actual gain of the amplifier.
Increase the input signal frequency from 1KHz to 100KHz and note down the measured
gain of the amplifier. Plot a graph of gain vs input signal frequency. Explain this graph in
your report.
Set the input signal frequency back to 1KHz. Now increase the peak amplitude from 0.5V
to 1V. Show and explain the resultant graph in your report. What can you do to make the
amplified signal look better?
________________________________________________________________________
Experiment # 05 Page 3 of 5
Electronic Circuit Design Lab
_________________________________________________________________________
Increase the input signal frequency from 1KHz to 100KHz and note down the measured
gain of the amplifier. Plot a graph of gain vs input signal frequency. Explain this graph in
your report and compare it with the graph obtained in previous task
________________________________________________________________________
Experiment # 05 Page 5 of 5
Electronic Circuit Design Lab