Professional Documents
Culture Documents
To,
The Sectional Engineer,
Alsand Section Office,
MSEDCL, Vita 2 Sub-division.
Subject: Regarding absurd/High DCL Losses under Vita 2 Sub division for August-22 Run.
With reference to the above subject, it is to inform you that, meeting was held at Sangli circle
office Regarding absurd/High DCL Losses of all subdivisions under Sangli Circle & Hon. SE Sir has
directed to improve the loss of All Industrial/MIDC/Urban & Gavthan Feeders & it must be brought back
to Group A (i.e., below 15% level). Hence, the position of such feeders under Vita 2 Sub division for
August-22 Run have been shown as under.
Hence, after observing the above position of your feeders, it is necessary to bring all the feeders
to necessary (upto 15%) loss level. Hence Following directive are to be observed.
1. Correct Mapping of DTC to that particular Feeder must match physically with that in
NDM Module.
2. Correct Mapping of all the Consumers w. r. to that DTCs.
3. Regular Theft detection, Hook Removal if any.
4. Over Billing /Under Billing of consumers. Etc.
5. Manual DTC & feeder Energy Audit can be carried out.
Hence, you are hereby directed to carry out the above activities, at the earliest, so that correct
loss of that particular feeder can be observed & necessary actions can be taken. Improvement on these
above-mentioned feeders must be seen for further DCL Runs. Non submission or no work of the same
will be communicated to Higher authorities for further action as per rules, which may be please noted.
Hence your prompt action in this matter is required.
(Amit Kamble)
Dy. Executive Engineer,
VITa 2 Subdivision, MSEDCL.
1
Office of Deputy Executive Engineer, Vita 2
S/dn Near shaha petrol pump, Vita,
Taluka : Khanapur, Dist- Sangli.
Email ID: 1sdo6262@gmail.com
To,
The Sectional Engineer,
Pare Section Office,
MSEDCL, Vita 2 Sub-division.
Subject: Regarding absurd/High DCL Losses under Vita 2 Sub division for August-22 Run.
With reference to the above subject, it is to inform you that, meeting was held at Sangli circle
office Regarding absurd/High DCL Losses of all subdivisions under Sangli Circle & Hon. SE Sir has
directed to improve the loss of All Industrial/MIDC/Urban & Gavthan Feeders & it must be brought back
to Group A (i.e., upto 15% level). Hence, the position of such feeders under Vita 2 Sub division for
June-2022 Run have been shown as under.
Hence, after observing the above position of your feeders, it is necessary to bring all the feeders
to necessary (below 15%) loss level except 11kV Textile Park Feeder & also Absurd losses are to be
corrected immediately. Hence Following directive are to be observed.
1. Correct Mapping of DTC to that particular Feeder must match physically with that in NDM
Module.
2. Correct Mapping of all the Consumers w. r. to that DTCs.
3. Regular Theft detection, Hook Removal if any.
4. Over Billing /Under Billing of consumers. Etc.
5. Manual DTC & feeder Energy Audit can be carried out.
Hence, you are hereby directed to carry out the above activities, at the earliest, so that correct
loss of that particular feeder can be observed & necessary actions can be taken. Improvement on these
above-mentioned feeders must be seen for further DCL Runs. Non submission or no work of the same
will be communicated to Higher authorities for further action as per rules, which may be please noted.
Hence your prompt action in this matter is required.
(Amit Kamble)
Dy. Executive Engineer,
VITA- 2 Subdivision, MSEDCL.
2
Office of Deputy Executive Engineer, Vita 2
S/dn Near shaha petrol pump, Vita,
Taluka : Khanapur, Dist- Sangli.
Email ID: 1sdo6262@gmail.com
To,
The Sectional Engineer,
Lengre Section Office,
MSEDCL, Vita 2 Sub-division.
Subject: Regarding absurd/High DCL Losses under Vita 2 Sub division for August-2022 Run.
With reference to the above subject, it is to inform you that, meeting was held at Sangli circle
office Regarding absurd/High DCL Losses of all subdivisions under Sangli Circle & Hon. SE Sir has
directed to improve the loss of All Industrial/MIDC/Urban & Gavthan Feeders & it must be brought back
to Group A (i.e., upto 15% level). Hence, the position of such feeders under Vita 2 Sub division for
August-2022 Run have been shown as under.
Hence, after observing the above position of your feeders, it is necessary to bring all the feeders
to necessary (upto 15%) loss level & also Absurd losses are to be corrected immediately. Hence
Following directive are to be observed.
1. Correct Mapping of DTC to that particular Feeder must match physically with that in NDM
Module.
2. Correct Mapping of all the Consumers w. r. to that DTCs.
3. Regular Theft detection, Hook Removal if any.
4. Over Billing /Under Billing of consumers. Etc.
5. Manual DTC & feeder Energy Audit can be carried out.
Hence, you are hereby directed to carry out the above activities, at the earliest, so that correct loss
of that particular feeder can be observed & necessary actions can be taken. Improvement on these
above-mentioned feeders must be seen for further DCL Runs. Non submission or no work of the same
will be communicated to Higher authorities for further action as per rules, which may be please noted.
Hence your prompt action in this matter is required.
(Amit Kamble)
Dy. Executive Engineer,
VITa 2 Subdivision, MSEDCL.
3
Office of Deputy Executive Engineer, Vita 2
S/dn Near shaha petrol pump, Vita,
Taluka : Khanapur, Dist- Sangli.
Email ID: 1sdo6262@gmail.com
To,
The Sectional Engineer,
Nagewadi Section Office,
MSEDCL, Vita 2 Sub-division.
Subject: Regarding absurd/High DCL Losses under Vita 2 Sub division for August-2022 Run.
With reference to the above subject, it is to inform you that, meeting was held at Sangli circle
office Regarding absurd/High DCL Losses of all subdivisions under Sangli Circle & Hon. SE Sir has
directed to improve the loss of All Industrial/MIDC/Urban & Gavthan Feeders & it must be brought back
to Group A (i.e., upto 15% level). Hence, the position of such feeders under Vita 2 Sub division for
August-2022 Run have been shown as under.
Hence, after observing the above position of your feeders, it is necessary to bring all the feeders
to necessary (below 15%) loss level & also Absurd losses are to be corrected immediately. Hence
Following directive are to be observed.
1. Correct Mapping of DTC to that particular Feeder must match physically with that in NDM
Module.
2. Correct Mapping of all the Consumers w. r. to that DTCs.
3. Regular Theft detection, Hook Removal if any.
4. Over Billing /Under Billing of consumers. Etc.
5. Manual DTC & feeder Energy Audit can be carried out.
Hence, you are hereby directed to carry out the above activities, at the earliest, so that correct
loss of that particular feeder can be observed & necessary actions can be taken. Improvement on these
above-mentioned feeders must be seen for further DCL Runs. Non submission or no work of the same
will be communicated to Higher authorities for further action as per rules, which may be please noted.
Hence your prompt action in this matter is required.
(Amit Kamble)
Dy. Executive Engineer,
VITa 2 Subdivision, MSEDCL.
4
Office of Deputy Executive Engineer, Vita 2
S/dn Near shaha petrol pump, Vita,
Taluka : Khanapur, Dist- Sangli.
Email ID: 1sdo6262@gmail.com
To,
The Sectional Engineer,
Vita U-1 Section Office,
MSEDCL, Vita 2 Sub-division.
Subject: Regarding absurd/High DCL Losses under Vita 2 Sub division for August-2022 Run.
With reference to the above subject, it is to inform you that, meeting was held at Sangli circle
office Regarding absurd/High DCL Losses of all subdivisions under Sangli Circle & Hon. SE Sir has
directed to improve the loss of All Industrial/MIDC/Urban & Gavthan Feeders & it must be brought back
to Group A (i.e., upto 15% level). Hence, the position of such feeders under Vita 2 Sub division for
August-2022 Run have been shown as under.
Hence, after observing the above position of your feeders, it is necessary to bring all the feeders
to necessary (below 15%) loss level except 11kV Vita Town Feeder & also Absurd losses are to be
corrected immediately. Hence Following directive are to be observed.
1. Correct Mapping of DTC to that particular Feeder must match physically with that in NDM
Module.
2. Correct Mapping of all the Consumers w. r. to that DTCs.
3. Regular Theft detection, Hook Removal if any.
4. Over Billing /Under Billing of consumers. Etc.
5. Manual DTC & feeder Energy Audit can be carried out.
Hence, you are hereby directed to carry out the above activities, at the earliest, so that correct
loss of that particular feeder can be observed & necessary actions can be taken. Improvement on these
above-mentioned feeders must be seen for further DCL Runs. Non submission or no work of the same
will be communicated to Higher authorities for further action as per rules, which may be please noted.
Hence your prompt action in this matter is required.
(Amit Kamble)
Dy. Executive Engineer,
VITa 2 Subdivision, MSEDCL.
5
Office of Deputy Executive Engineer, Vita 2
S/dn Near shaha petrol pump, Vita,
Taluka : Khanapur, Dist- Sangli.
Email ID: 1sdo6262@gmail.com
To,
The Sectional Engineer,
Vita U-2 Section Office,
MSEDCL, Vita 2 Sub-division.
Subject: Regarding absurd/High DCL Losses under Vita 2 Sub division for August-2022 Run.
With reference to the above subject, it is to inform you that, meeting was held at Sangli circle
office Regarding absurd/High DCL Losses of all subdivisions under Sangli Circle & Hon. SE Sir has
directed to improve the loss of All Industrial/MIDC/Urban & Gavthan Feeders & it must be brought back
to Group A (i.e., upto 15% level). Hence, the position of such feeders under Vita 2 Sub division for
August-2022 Run have been shown as under.
Hence, after observing the above position of your feeders, it is necessary to bring all the feeders
to necessary (upto 15%) loss level except 11kV Vita Town Feeder & also Absurd losses are to be
corrected immediately. Hence Following directive are to be observed.
1. Correct Mapping of DTC to that particular Feeder must match physically with that in NDM
Module.
2. Correct Mapping of all the Consumers w. r. to that DTCs.
3. Regular Theft detection, Hook Removal if any.
4. Over Billing /Under Billing of consumers. Etc.
5. Manual DTC & feeder Energy Audit can be carried out.
Hence, you are hereby directed to carry out the above activities, at the earliest, so that correct
loss of that particular feeder can be observed & necessary actions can be taken. Improvement on these
above-mentioned feeders must be seen for further DCL Runs. Non submission or no work of the same
will be communicated to Higher authorities for further action as per rules, which may be please noted.
Hence your prompt action in this matter is required.
(Amit Kamble)
Dy. Executive Engineer,
VITa 2 Subdivision, MSEDCL.
6
Office of Deputy Executive Engineer, Vita 2
S/dn Near shaha petrol pump, Vita,
Taluka : Khanapur, Dist- Sangli.
Email ID: 1sdo6262@gmail.com
To,
The Sectional Engineer,
Alsand, Pare, Lengare, Nagewadi, Vita U-1 & Vita U-2,
MSEDCL, Vita 2 Sub-division.
Subject: Regarding Non -AG Paid Pending applications under Vita 2 Sub division.
With reference to the above subject, it is to inform you that, Non -AG Paid pending
applications are to be cleared at regular basis, as this activity is closely monitored by Higher
Authorities. Following abstract section wise showing that, large amount of paid pending applications is
pending at section office level. There are possibilities that, those connections might have been issued
and it has not been released through NC Portal & the case may be vice versa also. Following report of
dated 17.10.2022 is given herewith.
INFRA NOT
REQUIRED/INFRA INFRA REQUIRED
Section COMPLETED Grand Total
Name
SINGLE THREE SINGLE THREE
Total Total
PHASE PHASE PHASE PHASE
ALSAND 8 1 9 39 0 39 48
LENGARE 20 0 20 13 3 16 36
NAGEWADI 15 2 17 39 5 44 61
PARE 6 1 7 15 8 23 30
VITA(U) 1 30 4 34 5 2 7 41
VITA(U) 2 15 6 21 3 2 5 26
Grand Total 94 14 108 114 20 134 242
Hence, you are directed to release the connections immediately physically & thru’ NC Portal
which does not require infra & also it is further directed to verify the Consumers required Infra & submit
the action taken report within 7 days to this office positively. Also, it is to instruct that, All the A1
application pending at various stages also to be cleared at regular intervals. Non submission or
no work of the same will be communicated to Higher authorities for further action as per rules, which
may be please noted. You will be held responsible for non-reporting of the Infra Required Consumers.
Hence your prompt action in this matter is required.
(Amit Kamble)
Dy. Executive Engineer,
VITa 2 Subdivision,
MSEDCL.
Copy s. w. rs. To:
7
Office of Deputy Executive Engineer, Vita 2
S/dn Near shaha petrol pump, Vita,
Taluka : Khanapur, Dist- Sangli.
Email ID: 1sdo6262@gmail.com
महोदय,
मला श्रीरामपुर वभाग येथे, उपकार्यकारी अभियंता ह्या पैदावार कार्यरत असताना तथाकथित ग़ैरकृत्याबाबत वरील
संदर्भ पत्र क्र. १ नुसार आरोपपत्र बजावण्यात आलेले होते। सदर आरोपपत्राची सखोल विभागीय चौकशी संदर्भ पत्र क्र. २
अन्वये चौकशी अधिकारी नियक्ति
ु करुन दिनांक १२. ०८. २०२२ रोजी करण्यात आली. सदर चौकशीमध्ये मला आरोपपत्र
संदर्भातील कागदपत्रे मिळाली नसल्याचे नमूद केल
चौकशी अधिकारी यांनी आरोपपत्राच्या चौकशी संदर्भातील चौकशीचे निष्कर्ष पत्र क्र. ३ नुसार सादर केलेला आहे .
सदर अहवालानुसार आरोपपत्रामध्ये ठे वण्यात आलेल्या सहा आरोपपंपैकी २ आरोप सिद्ध झाल्याचे चौकशी कळविले आहे .
आपण सक्षम अधिकारी ह्या नात्याने सदर चौकशी अहवाल स्वीकारून खालील शिक्षा प्रस्तावित केलेली आहे . "आपल्या
येणाऱ्या दोन (२) वार्षिक वेतन वाढ संचयी परिणामसह रोखणे."
आपण अहवालाच्या आधारे केलेली अवाजवी व ् कंपनीचे कोणतेही आर्थिक नुक्सान झालेले नसताना प्रस्तावित केलेली
शिक्षा मला मान्य नाही. मला सदरची शिक्षा मान्य नसल्याची कारणमीमांसा खालील प्रमाणे आहे .
8
Office of Deputy Executive Engineer, Vita 2
S/dn Near shaha petrol pump, Vita,
Taluka : Khanapur, Dist- Sangli.
Email ID: 1sdo6262@gmail.com
करण्याची जबाबदारी ही व्यवस्थापनाची असताना सुद्धा व्यवस्थापनाने आरोप पुरव्यासह सिद्ध केलेले नाहीत. अशा वेळेस
स्वत:चे निर्दोषत्व आरोपित कर्मचाऱ्याने कैसे करावे व ् कशाच्या आधारावर करावे त्याबाबतचे विश्लेषण अथवा स्पष्टीकरण
चौकशी अधिकारी यांच्या अहवालात नाही. तसेच, चौकशी अधिकारी यानि कोणत्याही पुरव्याचा आधार न घेता त्यांच्या
चौकशी अहवालामध्ये केलेले आरोप सिद्ध केलेले नाहीत, त्यामुळे आरोपपत्राच्या आधारावर आपण वरील शिक्षा प्रस्तावित
केलेली आहे , ती आवाजावी व ् अमान्य आहे .
ह्या ठिकाणी आरोपपत्रामध्ये सिद्ध केलेल्या आरोप संबंधीचे खालील प्रमाणे खंडन करीत आहे . आरोप क्र. २ व ् ६
सिद्ध करताना घटना क्र. १ ते ३ मधील ज्या बाबींचा उहापोह केलात्याबद्दल विश्लेषण वजा खंडन खलील प्रमाणे करीत आहे .
घटना क्र. १
ह्या आरोपसंदर्भात चौ अ यानी असे नमद
ू केले की' " आ. क. ह्यानी घटना क्र. १ च्या बाबतीत स्थळ तपासणी
अहवालावर काय कार्रवाई झाली यावर दक्ष रहूं सातत्याने पाठपुरावा केला असता, तर कंपनीचा महसूल अडला नसता " ह्या
त्यांच्या निष्कर्ष अहवालाच्या विपरीत घटना क्र. १ पान क्र. १० वर " दरम्यान व्य. प्र. यानी "सदर प्रकारणांमध्ये स्थळ
तपासणी अहवालावर आ. क. यानी त्याबाबत सूचना दिल्याचे गहृ ीत धरुन त्याचा पाठपरु ावा न केल्याबद्दल आ. क. याना दोषी
ठरविणे उचित होणार नाही, किं बहुना ती जबाबदारी सम्बंधित सहाय्यक अभियंता व ् त्या विभागातील विज बिल प्रमख
ु या
नात्याने यांची होती असे आ. क. प्र. यानी म्हं टलेले आहे व ् ताशा अशयाचा पुरवा चौकशी पटलावर सादर झालेला आहे . ह्या
पुरव्या वरुन आ. क. यानी या प्रकरणमध्ये पाठपुरावा केला नहीं हे म्हणणे गैर लागू ठरते.”
वरील दोन्ही निष्कर्षांमध्ये चौ अ यांची पाठपरु व्या बाबत विसंगती आहे . मी उपकार्यकारी अभियंता ह्या नात्याने
पाठपुरावा केलेला ह्या संबंधीची कोणतीही कागदपत्रे पुरावा म्हणून सादर झालेली नाहीत, अशा वेळेस मला पाठपुरावा केला
नाही म्हणन
ू दोषी धरणे हे नियमाधीन नाही. उत्तपरपक्षी महावितरण कंपनीच्या कार्यप्रणालीनस
ु ार सम्बंधित विभागाच्या
विभाग प्रमुखाने पाठपुरावा करावयाचा असतो त्याबाबाबतचा पुरावा म्हणून महाराष्ट्र राज्य विद्युत ् मंडल यांचे manual of
office procedure for Head Quarter Offices मधील प्रकरण १२ मधील आ.क. ५६, नस
ु ार चौकशी पटलावर दस्तऐवज क्र ४
एकूण पाने ४६ ठे वलेली आहे त.
बिलिंग विभागाचे विभाग प्रमुख हा AA /UDC असतो तसा पाठपरु ावा त्यानी करणे बंधन कारक असते . ज्या वेळेस
मी दिलेल्या सूचनांचाच पुरावा चौकशी पटलवार सादर झालेला नसताना, मी पाठपुरावा केला नाही त्याबाबत दोषी धरने
चुकीचे आहे व ् जनून बुजुन ओढून ताणन
ु आरोप सिद्ध करण्यासारखे आहे . निष्कर्ष नोंदवत असताना तो पुरव्यासह नोंद करने
आवश्यक आहे , तथापि इथे जर तर ची भाषा वापरलेली आहे , जी सयक्ति
ु क नाही.
जर उपविभागीय अधिकारी प्रत्येक बाबतीत जबाबदार असतील तर माझे सर्व वरिष्ठ अधिकारी हे सुद्धा जबाबदार
आहेत व ् त्याचप्रमाणे महावितरणाचे सवा सेवा विनियम कलम ५ हे रद्दबातल ठरविण्यात यावे.
घटना क्र. २
घटना क्र. १ मधील सर्व विश्लेषण ह्या ठिकाणी लागू होतात. घडलेल्या घटनांच्या क्रमामध्येजागतिक महामारी
कोविड -१९ चा कार्यकाल सद्ध
ु ा होता , यामध्ये चौ अ . यानी जनून बुजुन दर्ल
ु क्ष केल्याचे दिसते. प्रत्येक ग्राहकास रीड़िंग
9
Office of Deputy Executive Engineer, Vita 2
S/dn Near shaha petrol pump, Vita,
Taluka : Khanapur, Dist- Sangli.
Email ID: 1sdo6262@gmail.com
प्रमाणे बिल जाते किवा कैसे उपविभागीय अधिकारी बघत नसून बिलिंग कार्यक्षमता वाढली की नाही हे बघणे आहे व ्
बिलिंग कार्यक्षमता माज़्या कार्यकाळात वाढलेली आहे .
घटना क्र. ३
वीजचोरीच्या ग्रहकाकडे विशेष लक्ष दे ने क्रमप्राप्त होते असे नमूद केलेले आहे . ह्या ठिकाणी सुद्धा निष्कर्षांमध्ये
विसंगति आहे . हयाबाबतचा पाठपुरावा केल्याचे चौ अ. ह्यांच्याच निदर्शनामध्ये नमूद केलेले आहे . ते पुढील प्रमाणे " सदर
मीटरचि तपासणी करण्यात यावी यासाठी सम्बंधित कक्ष अभियंता याना PC - ० मधील शुन्य (०) यूनिट बिल येत
असलेल्या ग्राहकांची तपासणी करण्याकरिता प्रत्येक महिन्यात कळविलेले होते, त्यामधील पत्र क्र. उका
/श्रीराम/उवि/बिलिंग/९८७ दिनांक १६.०६.२०२० व ् तदनन्तर कलविले होते त्याबद्दलचा पुरावा म्हणून आ. क. दस्तऐवज क्र.
१३ पाने १९ सोबत जोड़त आहे . हयाबाबतचे परु ावे व्यवस्थापनेने नाहीत सबब, त्याबाबतचा अधिक खल
ु ासा दे ता येत नाही.”
ह्यावरून पुरावा नसताना व ् व्य. प्र. यानी सुद्धा पुरावा सादर केलेला नसताना जर तर च्या आधारे चौ. अ. यानी आरोप
सिद्ध केलेले आहे त.
वास्तविक सम्बंधित कालावधि मध्ये मी स्वतः रजेवर होतो. मी कोविड १९ ह्या आजाराने ग्रासलेला होतो व ् त्याचे
पुरावे सुद्धा चौकशी पटलावर ठे वण्यात आलेले आहे त . परन्तु सदर पुरवाव्याचा कोणताही विचार न करता व ् ते त्यानी सदरची
माहिती निष्कर्षांमधे न मांडता असे आरोप सिद्ध करणे हे न्यायोचित व ् नियमाधीन नाही तरीही आपणास विनंती करण्यात
येते की, माज़्या विरूद्ध कोणतेही पुरावे नसताना आरोप सिद्ध करने हे नैसर्गिक न्याय तत्वाच्या विरुद्ध आहे , सबब मला
दोषरूपातन
ु दोषमक्
ु त करावे, ही विनंती.
त्याचप्रमाणे प्रत्यक्ष आपणास मला व ् माज़्या प्रतिनिधिस प्रत्यक्षात भेटून बाजू मांडण्याची संधी द्यावी, त्याशिवाय
अंतिम शिक्षा आदे श दे ऊ नए, ही विनंती.
आपला विश्वासू,
10
Office of Deputy Executive Engineer, Vita 2
S/dn Near shaha petrol pump, Vita,
Taluka : Khanapur, Dist- Sangli.
Email ID: 1sdo6262@gmail.com
To,
The Sectional Engineer,
Alsand Section Office,
MSEDCL, Vita 2 Sub-division.
Subject: Regarding absurd/High DCL Losses under Vita 2 Sub division for September-22 Run.
With reference to the above subject, it is to inform you that, meeting was held at Sangli circle
office Regarding absurd/High DCL Losses of all subdivisions under Sangli Circle & Hon. SE Sir has
directed to improve the loss of All Industrial/MIDC/Urban & Gavthan Feeders & it must be brought back
to Group A (i.e., below 15% level). Hence, the position of such feeders under Vita 2 Sub division for
September-22 Run have been shown as under.
Hence, after observing the above position of your feeders, it is necessary to bring all the feeders
to necessary (upto 15%) loss level. Hence Following directive are to be observed.
1. Correct Mapping of DTC to that particular Feeder must match physically with
that in NDM Module.
2. Correct Mapping of all the Consumers w. r. to that DTCs.
3. Regular Theft detection, Hook Removal if any.
4. Over Billing /Under Billing of consumers. Etc.
5. Manual DTC & feeder Energy Audit can be carried out.
Hence, you are hereby directed to carry out the above activities, at the earliest, so that correct
loss of that particular feeder can be observed & necessary actions can be taken. Improvement on these
above-mentioned feeders must be seen for further DCL Runs. Non submission or no work of the same
will be communicated to Higher authorities for further action as per rules, which may be please noted.
Hence your prompt action in this matter is required.
(Amit Kamble)
Dy. Executive Engineer,
11
Office of Deputy Executive Engineer, Vita 2
S/dn Near shaha petrol pump, Vita,
Taluka : Khanapur, Dist- Sangli.
Email ID: 1sdo6262@gmail.com
To,
The Sectional Engineer,
Pare Section Office,
MSEDCL, Vita 2 Sub-division.
Subject: Regarding absurd/High DCL Losses under Vita 2 Sub division for September-22 Run.
With reference to the above subject, it is to inform you that, meeting was held at Sangli circle
office Regarding absurd/High DCL Losses of all subdivisions under Sangli Circle & Hon. SE Sir has
directed to improve the loss of All Industrial/MIDC/Urban & Gavthan Feeders & it must be brought back
to Group A (i.e., upto 15% level). Hence, the position of such feeders under Vita 2 Sub division for
September-22 Run have been shown as under.
Hence, after observing the above position of your feeders, it is necessary to bring all the feeders
to necessary (below 15%) loss level except 11kV Textile Park Feeder & also Absurd losses are to be
corrected immediately. Hence Following directive are to be observed.
1. Correct Mapping of DTC to that particular Feeder must match physically with that in NDM
Module.
2. Correct Mapping of all the Consumers w. r. to that DTCs.
3. Regular Theft detection, Hook Removal if any.
4. Over Billing /Under Billing of consumers. Etc.
5. Manual DTC & feeder Energy Audit can be carried out.
Hence, you are hereby directed to carry out the above activities, at the earliest, so that correct
loss of that particular feeder can be observed & necessary actions can be taken. Improvement on these
above-mentioned feeders must be seen for further DCL Runs. Non submission or no work of the same
will be communicated to Higher authorities for further action as per rules, which may be please noted.
Hence your prompt action in this matter is required.
(Amit Kamble)
Dy. Executive Engineer,
12
Office of Deputy Executive Engineer, Vita 2
S/dn Near shaha petrol pump, Vita,
Taluka : Khanapur, Dist- Sangli.
Email ID: 1sdo6262@gmail.com
To,
The Sectional Engineer,
Lengre Section Office,
MSEDCL, Vita 2 Sub-division.
Subject: Regarding absurd/High DCL Losses under Vita 2 Sub division for September-22 Run.
With reference to the above subject, it is to inform you that, meeting was held at Sangli circle
office Regarding absurd/High DCL Losses of all subdivisions under Sangli Circle & Hon. SE Sir has
directed to improve the loss of All Industrial/MIDC/Urban & Gavthan Feeders & it must be brought back
to Group A (i.e., upto 15% level). Hence, the position of such feeders under Vita 2 Sub division for
August-2022 Run have been shown as under.
Hence, after observing the above position of your feeders, it is necessary to bring all the feeders
to necessary (upto 15%) loss level & also Absurd losses are to be corrected immediately. Hence
Following directive are to be observed.
1. Correct Mapping of DTC to that particular Feeder must match physically with that in NDM
Module.
2. Correct Mapping of all the Consumers w. r. to that DTCs.
3. Regular Theft detection, Hook Removal if any.
4. Over Billing /Under Billing of consumers. Etc.
5. Manual DTC & feeder Energy Audit can be carried out.
Hence, you are hereby directed to carry out the above activities, at the earliest, so that correct loss
of that particular feeder can be observed & necessary actions can be taken. Improvement on these
above-mentioned feeders must be seen for further DCL Runs. Non submission or no work of the same
will be communicated to Higher authorities for further action as per rules, which may be please noted.
Hence your prompt action in this matter is required.
13
Office of Deputy Executive Engineer, Vita 2
S/dn Near shaha petrol pump, Vita,
Taluka : Khanapur, Dist- Sangli.
Email ID: 1sdo6262@gmail.com
(Amit Kamble)
Dy. Executive Engineer,
VITa 2 Subdivision, MSEDCL.
To,
The Sectional Engineer,
Nagewadi Section Office,
MSEDCL, Vita 2 Sub-division.
Subject: Regarding absurd/High DCL Losses under Vita 2 Sub division for September-22 Run.
With reference to the above subject, it is to inform you that, meeting was held at Sangli circle
office Regarding absurd/High DCL Losses of all subdivisions under Sangli Circle & Hon. SE Sir has
directed to improve the loss of All Industrial/MIDC/Urban & Gavthan Feeders & it must be brought back
to Group A (i.e., upto 15% level). Hence, the position of such feeders under Vita 2 Sub division for
September-22 Run have been shown as under.
Hence, after observing the above position of your feeders, it is necessary to bring all the feeders
to necessary (below 15%) loss level & also Absurd losses are to be corrected immediately. Hence
Following directive are to be observed.
1. Correct Mapping of DTC to that particular Feeder must match physically with that in NDM
Module.
2. Correct Mapping of all the Consumers w. r. to that DTCs.
3. Regular Theft detection, Hook Removal if any.
4. Over Billing /Under Billing of consumers. Etc.
5. Manual DTC & feeder Energy Audit can be carried out.
Hence, you are hereby directed to carry out the above activities, at the earliest, so that correct
loss of that particular feeder can be observed & necessary actions can be taken. Improvement on these
above-mentioned feeders must be seen for further DCL Runs. Non submission or no work of the same
will be communicated to Higher authorities for further action as per rules, which may be please noted.
Hence your prompt action in this matter is required.
(Amit Kamble)
14
Office of Deputy Executive Engineer, Vita 2
S/dn Near shaha petrol pump, Vita,
Taluka : Khanapur, Dist- Sangli.
Email ID: 1sdo6262@gmail.com
To,
The Sectional Engineer,
Vita U-1 Section Office,
MSEDCL, Vita 2 Sub-division.
Subject: Regarding absurd/High DCL Losses under Vita 2 Sub division for September-2022
Run.
With reference to the above subject, it is to inform you that, meeting was held at Sangli circle
office Regarding absurd/High DCL Losses of all subdivisions under Sangli Circle & Hon. SE Sir has
directed to improve the loss of All Industrial/MIDC/Urban & Gavthan Feeders & it must be brought back
to Group A (i.e., upto 15% level). Hence, the position of such feeders under Vita 2 Sub division for
September-2022 Run have been shown as under.
Hence, after observing the above position of your feeders, it is necessary to bring all the feeders
to necessary (below 15%) loss level except 11kV Vita Town Feeder & also Absurd losses are to be
corrected immediately. Hence Following directive are to be observed.
1. Correct Mapping of DTC to that particular Feeder must match physically with
that in NDM Module.
2. Correct Mapping of all the Consumers w. r. to that DTCs.
3. Regular Theft detection, Hook Removal if any.
4. Over Billing /Under Billing of consumers. Etc.
5. Manual DTC & feeder Energy Audit can be carried out.
Hence, you are hereby directed to carry out the above activities, at the earliest, so that correct
loss of that particular feeder can be observed & necessary actions can be taken. Improvement on these
above-mentioned feeders must be seen for further DCL Runs. Non submission or no work of the same
will be communicated to Higher authorities for further action as per rules, which may be please noted.
Hence your prompt action in this matter is required.
15
Office of Deputy Executive Engineer, Vita 2
S/dn Near shaha petrol pump, Vita,
Taluka : Khanapur, Dist- Sangli.
Email ID: 1sdo6262@gmail.com
(Amit Kamble)
Dy. Executive Engineer,
VITa 2 Subdivision, MSEDCL.
To,
The Sectional Engineer,
Vita U-2 Section Office,
MSEDCL, Vita 2 Sub-division.
Subject: Regarding absurd/High DCL Losses under Vita 2 Sub division for September-22 Run.
With reference to the above subject, it is to inform you that, meeting was held at Sangli circle
office Regarding absurd/High DCL Losses of all subdivisions under Sangli Circle & Hon. SE Sir has
directed to improve the loss of All Industrial/MIDC/Urban & Gavthan Feeders & it must be brought back
to Group A (i.e., upto 15% level). Hence, the position of such feeders under Vita 2 Sub division for
September-22 Run have been shown as under.
Hence, after observing the above position of your feeders, it is necessary to bring all the feeders
to necessary (upto 15%) loss level except 11kV Vita Town Feeder & also Absurd losses are to be
corrected immediately. Hence Following directive are to be observed.
1. Correct Mapping of DTC to that particular Feeder must match physically with
that in NDM Module.
2. Correct Mapping of all the Consumers w. r. to that DTCs.
3. Regular Theft detection, Hook Removal if any.
4. Over Billing /Under Billing of consumers. Etc.
5. Manual DTC & feeder Energy Audit can be carried out.
Hence, you are hereby directed to carry out the above activities, at the earliest, so that correct
loss of that particular feeder can be observed & necessary actions can be taken. Improvement on these
above-mentioned feeders must be seen for further DCL Runs. Non submission or no work of the same
will be communicated to Higher authorities for further action as per rules, which may be please noted.
Hence your prompt action in this matter is required.
16
Office of Deputy Executive Engineer, Vita 2
S/dn Near shaha petrol pump, Vita,
Taluka : Khanapur, Dist- Sangli.
Email ID: 1sdo6262@gmail.com
(Amit Kamble)
Dy. Executive Engineer,
VITa 2 Subdivision, MSEDCL.
17