Professional Documents
Culture Documents
Kami Export - Vicente Diaz - Table Saw Notes
Kami Export - Vicente Diaz - Table Saw Notes
riving
knife
on and
angle off
adjustment height switch
adjustment
and lock
Check blade height. The blade must not extend more than1/4 ________
quart of a
Stop the saw and __________ step out of the operating zone before
responding to someone trying to attract your attention.
Warped or twisted lumber that does not lay flat on the table may cause
a _______________.
accident Never cut without the instructor’s permission.
down
When cutting, the cupped side should face _______________.
Always stand to the ___________left of the blade when cutting. Never
stand to the _____________
right or directly behind the blade.
more
Never force wood into the saw _____________ than it can cut.
removing
Unplug the saw before ___________________ the blade.
Always reset the saw adjustments to the ______________ 0 position
(blade at 90 deg. to the table) after finishing an operation that required a
special set-up.
When ripping, the piece to be ____________ wood should be between the
blade and the fence. Also, push the piece all the way ____________ fence the
blade.
Never back out! Backing the wood out of a cut will cause a
problem
_________________. If you need to stop a cut or remove the wood,
always stop the saw.