Professional Documents
Culture Documents
Katelyn Spears - Table Saw Notes
Katelyn Spears - Table Saw Notes
fence
riving knife
miter gauge
miter slot
power switch
angle
adjustment
height
adjustment
1/4 in
Check blade height. The blade must not extend more than ________
inch maximum over the wood being cut.
always
Keep guards in place. The blade guard must ______________ be in
place except when the instructor has authorized its removal for special
work.
Never do this!!!! Do not try to ___________ move away scraps of wood
running
near the blade while the saw is ____________. More students than you
can believe have cut themselves __________ badly when trying to
move
___________ that little scrap of wood. Leave it alone!!!! Let the next
person
___________________ deal with it.
Crosscutting? Boards less that 6” wide _________ should
be crosscut on
band
the ____________ Saw!!!
Keep your fingers away from the ____________ cut line of the blade.
Your hand should never cross the saw line when the machine is in
operation. Arch your fingers when feeding wood into the machine;
avoid laying them ___________.flat
Always stand to the ___________ left of the blade when cutting. Never
right
stand to the _____________ or directly behind the blade.
more
Never force wood into the saw _____________ than it can cut.
removing
Unplug the saw before ___________________ the blade.
0
Always reset the saw adjustments to the ______________ position
(blade at 90 deg. to the table) after finishing an operation that required a
special set-up.
When ripping, the piece to be ____________ wood should be between the
blade and the fence. Also, push the piece all the way ____________ through the
blade.
Never back out! Backing the wood out of a cut will cause a
problem
_________________. If you need to stop a cut or remove the wood,
always stop the saw.