You are on page 1of 4
Uri ia: KEON <> REQUEST FOR INFORMATION FINO D-CRCC-RFLEL-00006 Rev.0 tivan-21 ‘To: KEO Intomational onsutents Prosect Poveacrace Downer ontnacron/consuTawt even ir eas ie nce ‘REQUEST: DDATE INFO REQUIRED : As soon possible ‘208 2014 & @1020-01000. ; PKG.000-FC-SPC-PMCO1 ‘sussect’ _UPS Project specification regards DRAWINGS / SPECS REF: ‘Agar 18 |Win relerence tothe above mentioned subject, kindly cart the following points, 1 As por attached project Speceston OVBI20 01000: PRE-DODFC-SPC-PHC-OT-A Sastan 2, PaA-TH ub dauzo ro 18.2628 state tat" (6) Aging lator of 125 (o) Design margin factor ol 115 lAzove Cemplance wil eadto ease UPS capacity and.cabie sizes sper stlached UPS datasheet kinaty aie, ST ee. a soe 12AN Refer ty allachadl seapmnae. = ee ey RECFIVED | | 23 JAN 2021 RD ‘ I winner teatens qs ))\ GI-BLD-CRCC-RFI-EL-00006 Rev 0 - KEO Reply 1. Contractor's inquity raises concerns over the Contractor / UPS specialist in sizing batteries to support the UPS capacities noted. 2. Aging andior temperature factors, design margin, Etc, as per applicable standards and in accordance with Contract Specifications shall be considered. RFI Retumed to Contractor accordingly ~~ 20/\ (2071 Ring Road, at Al Mana Intersection 149744462 6400 infosoic.corn P.O Box 18108, Doha, Qatar F #9744462 6500 vonwhevie comm Gewan Island, Qatar Specifications 20 Battery: High rate discharge, heavy duty, industrial, high impact resistant, clear plastic encased, scaled lead- acid (gas recombination) type cells with automatically re-closing explosion proof safety vents. Electrolyte specific gravity shall not exceed 1.25 when fully charged at 25 deg. C. Ampere-hour rating shall be sufficient for emergency period specified with all inverters operating at full rated output, to a discharge limit of not less than 1.75 V per cell. Cells shall be normally maintained at 2.25 V per cell. Guaranteed life shall not be less than 10 years, with a capacity drop down to not less than 80% under normal expected service. 21 Battery Cabinot: shall be factory assembled from UPS manufacturer, of welded consiruction and formed from heavy gauge steel with added supports to retain cabinet squareness and integrity during harsh shipping and handiing conditions, Adjustable battery rails or trays shall be provided to allow for multiple battery configurations and facilitate battery upgrades in the future, Heavy duty polyester strapping material shall be used to tie down batteries, Cabling shall be routed down the sides of the cabinet, away from the front of the batteries allowing full access for easy maintenance, series wiring shall be routed efficiently and neatly with tier to tior jumpers located at front batteries allowing for safe end easy maintenance, Cabinets shall be top coated with a hybrid epoxy-polyester powder coat and oven cured for a chip and ‘corrosion resistant long lasting finish, All circuit breakers usod on the cabinets shall be rated 10600 VDC. Each battery string shall be provided with its own circuit breaker for the individual string fault protection and disconnecting means. Battery cabinet enclosure degree of protection shall be IP 20, 22 Battery checking system shall be provided for each UPS to check the battery continuity and improve life time through regular automatic test and measurements for battery status, voltage and current. System shall provide a predictive and automatic diagnostics of battery health, ‘optimize the recharge time and provide an advance warning about the end of battery life upon detection of a weak / defective battery 23 The battery cells age, at the time of delivery Into site, shall be less than three months. | 24 Battery calculations according to IEEE 485 shal be cartod out by UPS supplier and submited for approval, based on the following: (a) Nominal active power factor of not less than 0.8 Lag. (b) Temperature factor for operation at 25 Deg C. 25 Mimic Panel: UPS assembly is to include a mimic diagram with digital and LED displays, indicating instruments and control devices, in ttue relative postions. 26 Local Panel Instruments are to include at least the following (digital readings) (a) _ Inverter input voltmeter, measuring d.c. bus volts, (b) Battery current: measuring charge / discharge currents, (©) AC. voltmeter to measure inverter output voltage, normal supply voltage or system output, (4) _ UPS output ammoter and frequency meter (e) Remaining battery backup time. (f) Input vottages. UNINTERRUPTIBLE POWER SUPPLY SYSTEMS (@18020-01000-PK3-000-FC-SPC-EL-01-A S21P18-Page 12 of 16 poReAtaT oq ROG SuaE | UEGT Sa] WAGE] SCOPES] —-StETE Tm 9 va] Maree] oe 0 ToHSADTSaT a a TE Far | na rae pRuouaIRYT at —enOe WUT PepeHiiTog Mow semeD/ ea San] WRNGE | UTESSSE | Sraete | acer wT HOST | —anET wae Tore ean PopeHierog prow some>/ wea san] WANOS | GLEvEPTT? | GLBISTE | —SITBT a ee | water | ast BaF THRBSLSIT PapeHan 99 prow 91RD / BURA Sen] —_WARST | SeSORETT | GEIST 3 7 7 RISE | AST SHOT ToRSSSSaT anenTan sq ROG FaIGED /UEA/ San] wavST | SCGORTTE | Sere ST 7 7 TASS |— AST HOF TSS Bopeiian se prow soaeD | ueaTSan] —WNOS | SELESVECy | —SeasEVE | —SLmBT cea Bee | wvsTe | —aINET 50 TOUS W ST PapeibGn ws BROW TaD | BURG TSA] —VANDE | —S0TEP ve oe % ¥ OPT] UNOS POOF TORS asa ‘apeitana pour seaes /euea/san] ANGI | StBOGtOT | —SeveSE | SHEE ra rz ROOT ca TREES Papedian sq prow sara /ovea/san] —wavos | steerer | Sia5636 | —GIBTE tH Fa | wore | anes Be TOUS WPS

You might also like