Professional Documents
Culture Documents
These are your installation instructions to connect your tado° Extension Kit to your boiler. Please follow the instructions
carefully and only confirm the successful installation once you have finished all the steps for all devices.
If you have any questions regarding the use or installation of tado° please consult our Help Center at www.tado.com/support
Version 4.3
Switching off your boiler and corresponding circuit breaker
Make sure that you take steps to ensure that the power Please leave a message at the circuit breaker box such
supply to your boiler is completely switched off and to inform everyone not to turn anything back on. Please be aware that your desktop computer
remains switched off during the installation process. In and lighting will turn off when you switch off
addition it is compulsory to remove the breaker/fuse that the mains power circuit breaker switch.
your boiler is connected to, or turn of the corresponding Please make sure that all residents of the
switch in your circuit breaker box. home are aware that you are going to turn
off and that you are the only one who is
If you are not 100% sure which is the allowed to switch it on again.
correct switch/breaker/fuse then you To provide safe lighting for the installation you
must remove all breakers/fuses or turn can use the flashlight function of your
off the main power switch in your circuit smartphone or a torch.
breaker box.
1
2
3
This step is very important, you will definitely
need this information in the future. Should
you need help, it will be difficult for our
Technical Support Team to assist you
without the photos of all of the current
wiring.
You will need these photos to restore
your old system if you move house in
order to take your tado° with you. Please
save them in a place where you will find
them again in this case.
4
5
In order to activate the interface, the relay needs to be bridged. Please, insert a cable
bridge between the terminals RT and 24V of the boiler.
6
Using only a pen, add the wire colors to the labels as Write into the blank areas of the labels as shown below. Please attach the labels to the cables as shown in the
shown on the right. Please double check your work. image. Matching the cable colors with the colors written
on the stickers is mandatory. Please double check your
work now.
7
8
Please do not mount the tado° Extension Kit to the boiler itself.
9
10
Please ensure that the terminal block of the
tado° Extension Kit should be on the top.
11
12
13
14
15
16
If the LED is shortly blinking 2x followed by a pause it means that pairing has failed.
Restart the process by pressing and holding the button for about 3 seconds until the LED starts blinking rapidly.
17
You have now successfully completed the installation of your tado° Extension Kit. Please log back into your account and continue with the installation as displayed there.
18