Professional Documents
Culture Documents
HL-211SL
High Functionality and Practicality
Increase Cost Effectiveness!
Screen Manual Headlight Tester Flexibly Supports Lights that Become More Diverse
Aligning the Tester with the Light Center on the Alignment Screen
Smooth adjustment on the
alignment screen while looking at
the light distribution pattern.
Alignment screen
The industry's
first!
The indicator is a digital display. Finder type vehicle High/low irradiation direction (cm/10m) High 20.0 to 0 to low 40.0
Well-defined operation and display alignment device comes Left/right irradiation direction (cm/10m) Left 40.0 to 0 to right 40.0
increase the operating as standard.
Luminosity/irradiation direction Digital/dial type
method
performance. * The photo shows HL-211S.
Display
* Scope type vehicle alignment device is optional.
Light alignment Image screen/cross laser
Power supply (V) 4 D batteries for power/laser
Tester dimensions (mm) W800×D681×H1,525
Tester weight (kg) Approx. 58
Auxiliary light cover ×1, light receiver cover ×1
Standard accessories
convex rule ×1 (supplied with the tester), D battery ×4
Standard rail dimensions (mm) W420×L4,500
Applicable rail width (mm) 360, 480, 550, 600
Option Scope type vehicle alignment device, vehicle alignment laser pointer, protection fence
Note: If the light distribution in the horizontal part of the cutoff line is blurred or irregular, or if the light distribution in the rising part is
The weight of the tester has been A useful convex rule comes as special, correct measurement of the light may not be possible.
reduced by using a sheet metal standard.
frame for the entire body.
Smooth movement increases the
operating performance. Response to New Standards as a Result of Revised Safety Standards for the Headlights
As a result of the Inspection Flow at Service Shop
establishment of safety
standards details by The high-beam light has passed the inspection according to the old standards
notification in the official Yes No
■ External Dimensions gazette, the inspection
method of the headlights
was changed effective Finished (passed) Was the vehicle produced on or after September 1, 1998?
September 1, 1998, so the Yes No
measurement of the
low-beam was added to the
current measurement of the Is the adjustment possible by service
high-beam so that the according to the old standards?
headlights are inspected by Adjust the low-beam light
measuring the high-beam Use the headlight tester for
Yes No
and low-beam. low-beam light measurement
460 Finished (passed) Finished (failed)
Yes No
1525
(150.8)
1998, the low-beam light Finished (passed) Finished (passed) Finished (passed)
543
must be reinspected.
800 681 Indicates the points according
to the new standards No or difficult to judge
■ Before using this product, carefully read the precautions indicated by DANGER, WARNING, and CAUTION in the manual supplied with this product to ensure correct use.