Professional Documents
Culture Documents
ETHERNET
GX TOUCH 50 HDMI
75%
+ victron energy
It is recommended that the connected used in this drawing, the maximum open circuit voltage of the connected array cannot output. Be aware of the 1:1 rule of any AC PV inverter size to the Multi RS size, and 1250W
strings are made with the same number exceed 432 volts. Where the array voltage exceeds this parameter the system will give minimum battery sizing applies. More information about these limitations are available in 870W
DC Power
and type of panels. The max operational a "Over-charge Protection" error and shuts down. To correct this, simply reduce the the Victron AC Coupling manual, and this document is required reading if using any AC 51.2V 17A -....W
input current for the MPPT is 18A. PV voltage by removing a panel from the Array string. PV inverter. More info is available in the Multi RS manual and on the website. victron energy
CERBO Power -
victron energy
BLUE POWER
Remote L
Remote H
ON/OFF SWITCH
ON/OFF SWITCH
60 Volt/16mA
PRE-ALARM BUZZER
From central negative MPPT RS remote-L/5
Opional SmartSolar MPPT RS
All BMS M8 Circular connectors are
daisy chained connected to the BMS !
WARNING ! WARNING !
1 N 1 N
High Voltage DC High Voltage DC
name name
PV PV
name
ADxxxxx xxA/I n0.03A
:hager :hager :hager name
ADxxxxx xxA/I n0.03A
:hager :hager :hager name 0 OFF 0 OFF
BREAKER 0 OFF 0 OFF
BREAKER
Bx
T Bx
T ISOLATOR ISOLATOR
Li-DISTRIBUTION
test regularly test regularly
EC
2 N 2 N power power
OT
PR
N
OF F I G N I T I O
I/O-6 Remote-H
I/O-5 Remote-L
OFF
Multi RS Multi RS
HOUSE
AC Out-1 AC Out-2 AC in
G TO
VE.Can
HIN
ve
mo
I TC
Re
SW
R
E
E FO
E B
GIN
I/O-6 Remote-H
S T OP E N
I/O-5 Remote-L
Single Circuit
VE.Can
Drawing BJE-303A
Smart LiFePO4 Switched load-3
BMS 1A fuse
Cerbo 1A fuse
25.6V-200Ah Switched load-2
Lithium Switched load-1
No Break load-3
No Break load-2
BLUE POWER
victron energy No Break load-1
Battery Pre Main Fuses
BF2|58V
BF2|58V
150A
150A
200A
200A
ANL
ANL
5x20
5x20
DIN END STOP
FUSE FUSE
WARNING !
230V Volt AC
Multi RS AC IN
victron energy
Main Fuse
BLUE POWER
To/From Cerbo
Terminal
Multi RS
Multi RS AC OUT-2
Din Rail
7
2 AUX_IN- Common negative for programmable auxiliary inputs
3 AUX_IN1+ Programmable auxiliary input 1 positive connection
8
BLUE POWER
victron energy 4 AUX_IN2+ Programmable auxiliary input 2 positive connection
5 REMOTE_L Remote On/Off connector Low or ATC connection with SmallBMS
VE.Direct VE.Direct
9
6 REMOTE_H Remote On/Off connector High or ATD connection with SmallBMS
10
4
7 RELAY_NC Programmable relay Normally Closed connection
8 RELAY_COM Programmable relay Common negative
11
5
9 TSENSE- Temperature Sensor negative
KEEP NEGATIVE BATTERY CABLES ALL AS SHORT KEEP POSITIVE BATTERY CABLES ALL AS SHORT VE.Can TERMINATOR VE.Can 10 TSENSE+ Temperature Sensor Positive VE.Can TERMINATOR VE.Can
12
6
11 VSENSE- Voltage Sensor negative
AS POSSIBLE AND ALL AT THE SAME LENGTH ! AS POSSIBLE AND ALL AT THE SAME LENGTH ! 12 VSENSE+ Voltage Sensor Positive
7
all adds up to the max sum of input and AC IN power source as they are internally distance between the batteries and the Multi RS depends heavily on the size of the
output current of 32+26=58A. An Earth connected. An Earth leakage device with connections !!! Recommendations are without connected power source.The input current
2
8
leakage device with breaker or a breaker or a combination MCB/RCD must other loads in the system and these also should be must be adjusted to fit the size of the
3
9
combination MCB/RCD must be installed be installed on the output. Cable size must taken into account for proper main battery, main connected power source. User I/O User I/O
on the output. Cable size must be adjusted be adjusted accordingly. fuse & main switch cables !!! The breaker and cable size for AC IN From SmallBMS From SmallBMS
10
10
4
4
accordingly. Fuse size should be 125-150A. should be adjusted accordingly.
ATC or CHARGE DISCONNECT-L/5 ATC or CHARGE DISCONNECT-L/5
11
11
5
5
ATD or LOAD DISCONNECT-H/6 location: ATD or LOAD DISCONNECT-H/6 location:
12
12
6
6
Bottom left hand side Bottom left hand side