Professional Documents
Culture Documents
VS.RRC.Rej.Power.Cong+VS.RAB.FailEstPs.Power.Cong+VS.RAB.FailEstCs.Power.Cong
Currently for uplink we use Equivalent Number of User to do CAC; for downlink we
use TCP to do CAC. According to our CAC strategy, first make sure some basic
parameters should be configured as follows:
ADD CELLALGOSWITCH: CellId=0, NBMUlCacAlgoSelSwitch=ALGORITHM_SECOND,
NBMDlCacAlgoSelSwitch=ALGORITHM_FIRST;
ADD CELLCAC: CellId=0, UlTotalEqUserNum=150;
Solution
If the configuration is correct and power congestion still happen, we recommend
solutions as follows:
Uplink power congestion:
If RTWP is always very high (more than -90dBm), most probability it was caused
by uplink interference. Then first check whether interference problem, if uplink
interference problem, then solving interference is the recommended method.
2014-10-21 华为机密,未经许可不得扩散 第 1 页, 共 2 页
文档名称 文档密级:
If TCP ratio is very high, it means downlink power congestion. Then we can:
Then we can monitor the counters as follows to check the effect of LDR action:
VS.LCC.LDR.InterFreq
VS.LCC.LDR.BERateDL
VS.LCC.LDR.BERateUL
Note: usually power congestion will not happen in dual carrier cell. For single carrier
site, if power congestion is serious, expand carrier is recommended.
2014-10-21 华为机密,未经许可不得扩散 第 2 页, 共 2 页