Professional Documents
Culture Documents
Increase of Viscosity
Application Areas: after 15 minutes, mPas ~3,400
LOCTITE LIOFOL LA 7825 / LA 6230 is suitable for the after 30 minutes, mPas ~6,300
lamination of transparent, metallised films and foils for food after 60 minutes, mPas ~16,800
packaging. At transparent substrates, laminates produced
with LOCTITE LIOFOL LA 7825 / LA 6230 are boiling
resistant. It can also be used for medium to high slip
containing films, white pigmented PE-films and EVA-films. Compliance with food packaging regulations:
For white pigmented PE-EVA films we recommend LOCTITE Under specific conditions LOCTITE LIOFOL LA 7825 / LA
LIOFOL LA 7780 / LA 6080 . 6230 is suitable for manufacturing of food packaging
materials under the applicable FDA, EC-provisions and/or
Product Properties: BfR recommendations.
Reaction of the two components produces an adhesive film A food contact statement with further details is available on
with high polymer content which shows good adhesion on request.
various substrates. The cured adhesive film is transparent, The responsibility for compliance with the specific conditions
odorless, elastic and age-resistant. is with the converter and not with the adhesive supplier.
DIRECTIONS OF USE
Preliminary Statement:
Prior to application it is necessary to read the Safety Data
Sheet for information about precautionary measures and
safety recommendations. Also, for chemical products exempt
from compulsory labeling, the relevant precautions should
always be observed. Please also refer to the local safety
instructions and contact Henkel for analytical support.
TDS LOCTITE LIOFOL LA 7825 / Hardener LA 6230, August-2022
Increase of viscosity:
Product Range:
Please refer to the Technical Data section of this datasheet.
Apart from LOCTITE LIOFOL LA 7825 / LA 6230 we can
Working Conditions: offer the following products for the manufacture of film/foil
Precise web tension control together with a suitable winding laminates:
program helps to avoid tunneling as well as telescoping and ● Solventbased, solventless and waterbased laminating
curling effects. adhesives for flexible packaging and special
applications
Cleaning: ● Adhesives for High Gloss Lamination
In case of a machine stop (for more than 30 minutes) the
● Primer for Extrusion and PVDC-coating
coating unit has to be cleaned with solvents/plasticizer-
mixture (observe safety precautions) or products of ● Coldseal Adhesives
the LOCTITE LIOFOL CL range (seperate datasheets ● Heatseal Coatings
available upon request). The 2 component dosing unit has to ● Special Cleaning agents
be cleaned. The same cleaning procedure has to follow at To obtain product specifications please ask for the relevant
the end of the run. technical datasheets.
Curing:
The laminates may be rewound and slit after 1 to 2 days.
Manufacture of triplex laminates is possible 24 hours after
duplex production.
Complete curing i. e. total resistance to severe environments
will be achieved after 3 to 5 days of storage at room
temperature depending on film combination and intended
use of the laminates.
STORAGE
When stored in a dry and cool place in the original unopened
container storage life is as follows. Once opened, containers
have to be tightly reclosed immediately and consumed within
a short time span.
Shelf life:
LOCTITE LIOFOL LA 7825, months: 9
LOCTITE LIOFOL LA 6230, months: 12
TDS LOCTITE LIOFOL LA 7825 / Hardener LA 6230, August-2022
Disclaimer
The information provided in this Technical Data Sheet (TDS) including the
recommendations for use and application of the product are based on our
knowledge and experience of the product as at the date of this TDS. The
product can have a variety of different applications as well as differing
application and working conditions in your environment that are beyond our
control. Henkel is, therefore, not liable for the suitability of our product for the
production processes and conditions in respect of which you use them, as well
as the intended applications and results. We strongly recommend that you
carry out your own prior trials to confirm such suitability of our product. Any
liability in respect of the information in the Technical Data Sheet or any other
written or oral recommendation(s) regarding the concerned product is
excluded, except if otherwise explicitly agreed and except in relation to death
or personal injury caused by our negligence and any liability under any
applicable mandatory product liability law.
Trademark usage
Except as otherwise noted, all trademarks in this document are trademarks of
Henkel Corporation in the U.S. and elsewhere. ® denotes a trademark
registered in the U.S. Patent and Trademark Office.
Reference 0.1
Henkel AG & Co. KGaA Henkel Corporation Henkel Diadema Henkel (China) Co.Ltd. Henkel Jebel Ali FZCO
40191 Düsseldorf, Germany Cary, NC 27511, USA Diadema - SP, Brasil 201203 Shanghai, China Dubai, UAE
Phone: +49-211-797-0 Phone: +1-919-319-1933 Phone: +55-11-3205-8955 Phone: +86-21-2891-8000 Phone: +971-4-3893333