Professional Documents
Culture Documents
Extremely sturdy one-piece QDP scope mount, with multiple interface surfaces for
mounting accessories directly to the mount. Built-in level. 45-degree split rings for
better view of turrets. Various heights and tilts available.
D
A
C
6
6
6
5
D
4 Ideal Scope
Mounting System
3
2
5
5
C
4
B Screwlength gauge to
prevent accessory screws
from marring scope
ALWAYS check screw length with Tensioning screw for Scope level gauge
Håkan
Designed by
3
3
gauge before mounting interfaces as “The wedge” Tensioning screw for
torque adjustment
to avoid damage to scope! torque adjustment
A
Checked by
B
Material 6
Interfaces
Approved by
Mount ................ 7075 T651 Aimpoint Micro, Burris Fastfire, Trijicon RMR, Docter,
2
5
bilder tillbehör
an
ned by
Chec
ked by
Level ................... Clear plastic spirit level 4 Various Picatinny rails in different lengths and heights.
Date
Approv
ed by
Screws ................ M4 Tx20 rings & interfaces Tri-rails, Clip-On adapters, and various interfaces and
Date
Date
3
M4 Tx20 tensioning screws spacers for ACIs and other accessories. 2012
-03-1
3
b ilder A
tillbeh
2012-03-13
Date
2 ör
Edition
Shee
t
1/1
Edition
Notes on Mounting
1
1
The contact surfaces of the rings have grooves that can be scope rings. Powdered rosin is a very good gripping agent
1/1
Sheet
used for gluing the scope in place. Gluing may be a good that prevents the scope from moving, it is also very easy to
D
A
solution for bench rest shooters or for firearms that are used remove using some rubbing alcohol.
extensively in 4WD vehicles and in other applications with All mount screws are waxed from the factory.
severe vibrations. For normal use (including most military, Customers working in extreme conditions may want to
law enforcement, and civilian use) we recommend using a degrease the screws and screw holes and use Loctite 243
small amount of powdered rosin between the scope and the Blue instead. continues on next page
Spuhr AB
C O N TA C T
Made in Sweden