You are on page 1of 10

2/3/23, 7:43 PM Audio Amplifier SMPS Circuit IR2153 – Electronics Projects Circuits

This website makes use of cookies to enhance browsing experience and provide additional
functionality. Details
Audio Amplifier SMPS Circuit IR2153 Allow cookies

gevv | September 20, 2021 Updated 0 Comment

I shared many SMPS circuits made with IR2153. IR2153 is especially


suitable for use in amplifier power supplies, even in power amplifiers in
large companies, in mixers Power supply uses IR2153 on the SMPS
floor. (Yamaha EMX5000 mixer service manual ir2153)

I have been working on the SMPS circuit I have applied for a long time,
whenever I can, it was developed by utilizing the SMPS schemes of
different devices. Overload, short circuit, long-term load (200W) tests
were carried out. The power range of the SMPS Circuit can be
expanded, depending on some material and transformer core, it can provide power between 100W…800W. You
can use AT-ATX Power supply transformers to use it in low-power applications without dealing with SMPS
transformer winding, as I did. PC power supplies also have transformers of different powers.

EI28 – 80W…100W
EI33 – 180W…250W
ERL35 – 250…300W

It can give strength (according to my experience and guesses 🙂 ) max. The transformer needs to be cooled at
the limits, although it depends on how long you use your amp at high power.. I will talk about the power issue at
the end of the article. The fan cooling system in PC power supplies cools the transformer as well as the power
transistors, output diodes. In fact, heating, efficiency, etc. It’s also about the operating frequency of the circuit..

I used the stereo LM3886 module in the tests. Instead of the speaker, the load resistors are connected. At the
end of the video, there is a short audio test with the TDA7294 200W module. I don’t have a high-power speaker
at the moment… I quickly touched on many details in the video..

IR2153 Audio SMPS Circuit 100W-800W

https://320volt.com/en/audio-amplifier-smps-circuit-ir2153/ 1/10
2/3/23, 7:43 PM Audio Amplifier SMPS Circuit IR2153 – Electronics Projects Circuits

Audio Amplifier SMPS Circuit Diagram


This website makes use of cookies to enhance browsing experience and provide additional
functionality. Details
1. EMI filter and DC rectifier
2a, 2b. Additional winding and regulator stage that provides the supply voltage of the IR2153
AllowICcookies
3. IR2153 Driver stage
4. Overcurrent detection, protection stage
5. Secondary, DC output stage
6. Additional 12v voltage output for cooling fan

https://320volt.com/en/audio-amplifier-smps-circuit-ir2153/ 2/10
2/3/23, 7:43 PM Audio Amplifier SMPS Circuit IR2153 – Electronics Projects Circuits

This website makes use of cookies to enhance browsing experience and provide additional
functionality. Details
Allow cookies

https://320volt.com/en/audio-amplifier-smps-circuit-ir2153/ 3/10
2/3/23, 7:43 PM Audio Amplifier SMPS Circuit IR2153 – Electronics Projects Circuits

This website makes use of cookies to enhance browsing experience and provide additional
functionality. Details
Allow cookies

First of all, although there are no 100nf 275VAC capacitors in the 220V input, the circuit works smoothly, but
these materials are within the possibilities required for the filter or you can not use them for testing, but resistors
connected in parallel to the 10-ohm NTC and 220uf capacitors are required because IR2153 may fail in high
power circuits instead of NTC in high power circuits. Start circuits or high current NTCs are used by connecting
them in parallel.

My favorite part of the IR2153 IC was that the supply voltage could be provided with simple methods, usually by
limiting it with a 5…10W resistor.. but this method produces a lot of heat and takes up space, so I made 4 turns of
0.30mm wire outside the transformer, about 20…23V DC after DC rectification. This voltage is reduced to around
16V with a transistor and a zener regulator.

https://320volt.com/en/audio-amplifier-smps-circuit-ir2153/ 4/10
2/3/23, 7:43 PM Audio Amplifier SMPS Circuit IR2153 – Electronics Projects Circuits

The operating frequency of the SMPS circuit is around 37KHZ, and the IR2153 frequency is determined by the
values ​of the R17 and C16 elements. It is better to have a higher frequency, but we cannot increase it much
This website makes use of cookies to enhance browsing experience and provide additional
because we use a ready-made ATX transformer.
functionality. Details
For the first test; Before assembling the transformer, IRF730 mosfets and IR2153 IC, measure Allow cookies
the regulator
stage. At the cathode of the 16v zener, a voltage of around 16v should appear on the 16.8V IR2153 pin 1. The
100K 2W resistor provides the necessary voltage for the start. If everything goes well, when you run the circuit
after assembly, there should be a voltage between 18v…20v at the output of the F+ 100 ohm resistor.

For IRF730 mosfets, as you can see in the pictures, a small heatsink is sufficient, they get very little hot.

According to the voltage drop on the 0.47 ohm 3W resistor in the overload, short-circuit protection layer, the T5
2N5551 transistor turns the protection layer to cut the IR2153 supply frequency.

The overcurrent protection circuit can be active at low powers according to the internal resistance of the
transistors, hfe value and the tolerance of materials such as capacitors and resistors, and can switch to
protection (or vice versa). In this case, you need to lower the value of the R15 5.6K resistor.

They say UF1010 instead of MUR160, HER107 diodes can be used. You can use more powerful TO220 sheath
diodes instead of SR5100 5A 100V diodes on the secondary stage. PCB design was made accordingly

common anode diodes

https://320volt.com/en/audio-amplifier-smps-circuit-ir2153/ 5/10
2/3/23, 7:43 PM Audio Amplifier SMPS Circuit IR2153 – Electronics Projects Circuits

MUR1620CTR
U12C20A
This website makes use of cookies to enhance browsing experience and provide additional
H16C20A
functionality. Details
U16C20A
Allow cookies
NTE6244

common cathode diodes

H16C20C
MUR1620
NTE6240

In the ATX transformer, I evaluated the 5V outputs for 12V fan supply, in addition, I added a fan control circuit
with NTC sensor. You must short circuit it.

If you want the fan not to work at normal temperatures, you can use R35 resistance 20K…22K. With these
values, the fan starts to work above 50 degrees, and if you want it to run slowly at normal temperature, you can
use the resistance value between 33K…39K. It will be mounted on a 10K NTC amp cooler.

IR2153 SMPS circuit is ready Output from PC power supply With ERL35 transformer, it can give 2X30V 300W.
For higher powers, high-voltage filter capacitors, mosfets, transformer, shunt resistor power and value input,
output diodes, capacitor values ​must be changed in the file Harbinger, Titan service manuals it will give
inspiration..

ExcellentIT SMPS Transformer calculation program will do your job for transformer calculation Let’s not forget the
IR2153 frequency calculation program, all documents and programs are in the file.. The core of the transformer I
use is a little small compared to EI33, in the tests I determined the most suitable oscillator resistance value as
18K. depending on the situation, but I had no problems in long-term tests.

Finally, don’t forget to cover the 47k 2w, 100k 2w, 100 ohm 2w and fuse with heat shrink tubing placed vertically,
and insulation should be done in the cooler assembly of the mosfets. I say amp power supply, but it can be used
in different projects, for example, you can get 30v by rectifying with 2 diodes on the secondary output stage, and
you can use it for a regulated laboratory power supply. By using 2 Ready PC power supply transformers, more
power can be obtained from transformer winding etc..

PCB design of IR2153 SMPS Circuit was prepared with Sprint layout 6 PCB dimensions 100X86mm

https://320volt.com/en/audio-amplifier-smps-circuit-ir2153/ 6/10
2/3/23, 7:43 PM Audio Amplifier SMPS Circuit IR2153 – Electronics Projects Circuits

This website makes use of cookies to enhance browsing experience and provide additional
functionality. Details
Allow cookies

https://320volt.com/en/audio-amplifier-smps-circuit-ir2153/ 7/10
2/3/23, 7:43 PM Audio Amplifier SMPS Circuit IR2153 – Electronics Projects Circuits

This website makes use of cookies to enhance browsing experience and provide additional
functionality. Details
Allow cookies

https://320volt.com/en/audio-amplifier-smps-circuit-ir2153/ 8/10
2/3/23, 7:43 PM Audio Amplifier SMPS Circuit IR2153 – Electronics Projects Circuits

This website makes use of cookies to enhance browsing experience and provide additional
functionality. Details
Allow cookies

https://320volt.com/en/audio-amplifier-smps-circuit-ir2153/ 9/10
2/3/23, 7:43 PM Audio Amplifier SMPS Circuit IR2153 – Electronics Projects Circuits

This website makes use of cookies to enhance browsing experience and provide additional
functionality. Details
Allow cookies

FILE DOWNLOAD LINK LIST (in TXT format or file): 27704a.zip pass: 320volt.com

Published: 2021/09/20 Tags: power electronic projects, smps circuits, smps projects, smps schematic

Electronic Circuits projects, circuit diagrams. Hidden Electronics secret circuits Programming Arduino Project

Microcontroller Amateur electronics Hobby | Terms of Use - Cookie Policy - Privacy Policy © 2006 2021 | 320volt.com

https://320volt.com/en/audio-amplifier-smps-circuit-ir2153/ 10/10

You might also like