Professional Documents
Culture Documents
Steps For White Optimization
Steps For White Optimization
SDI_test_page_v1.1.pdf
To test for correct SDI installation
• Paper
Curious Collection SKIN Black provided by antalis is good to use for white dry ink setups.
STEP 1 Automatic Adjustments
• Run Auto Density procedure
Test Job
Transfer Down : General way you want to go for CMYK on top of white
Fuser Temp Up :
Test Job
STEP 3 New Calibration Set/Profile
• Run New Calibration Set/Profile
Custom profiling should be done on a neutral colored stock with good transfer or a very light
pastel stock.
During profiling:
White underlay MUST be turned on manually at Job Properties at the Command Work
Station. (CPS still has a glitch with this. It will send the job with the SDIs off even if you had
turned it on.)
It MUST be done as a “Full page” white under. Otherwise the patches for ‘paper white' will
measure the color of the stock vs. SDI white. Skin tones and neutrals will skew.
Test Job
Test Job