Professional Documents
Culture Documents
SECTION 03150
CONCRETE ACCESSORIES
PART 1 - GENERAL
1.02 REFERENCES
1.03 SUBMITTALS
A. Deliver materials as factory packaged, sealed and labeled. Handle and protect as
necessary to prevent damage or deterioration during shipment and handling. Store
materials in a dry location secure from weather and construction operations. Remove
damaged materials from the site and dispose of in accordance with applicable
regulations.
1.07 WARRANTY
B. Upon notification of such defects, within the warranty period, make the necessary
repairs and replacements including removal and replacement of work superimposed
on the coating system, at the convenience of the Owner.
PART 2 - PRODUCTS
03150 - 1
2.01 MATERIALS
PART 3 - EXECUTION
3.01 INSPECTION
A. Examination : Installer shall examine concrete and conditions under which work is to
be performed and verify that conditions are satisfactory for the installation of the
swellable waterstop. Installer shall notify the Architect, in writing, of circumstances
detrimental to proper completion co work. Do not proceed with work until
unsatisfactory conditions are corrected.
B. Weather Conditions: Installation shall not proceed when work areas are flooded to the
extent that would cause the swellable waterstop to hydrate; nor when precipitation can
be reasonably anticipated before it can be properly installed or protected. Consult with
manufacturer’s representative as necessary to ensure adequate protection of
waterstop.
3.02 INSTALLATION
A. Install the system in accordance with the manufacturer’s instruction, except where
more stringent requirements are shown or specified.
A. Testing : After curing, test for leaks by filling the water tanks with water. Examine the
leaks and repair and re-test until no leakage is observed.
- END OF SECTION -
03150 - 2