Professional Documents
Culture Documents
CALCULATION
A. DIMENSIONAL REQUIREMENTS CHECK
(AISC 14th Ed. Specifications Chapter G, Section G5.2, page 16.1-29)
1. Requirement 1: b e a
Distance from edge of the hole to the edge of the
part measured in the direction normal to the applied force,
Dh
b Leh if θmax = 0 deg
2
Dh Dh
min Leh Lev otherwise
2 2
b 39 mm
Limiting edge distance,
b e min( b 2 tpl 16 mm)
b e 39 mm
2. Requirement 2: a 1.33be
Shortest distance from edge of the pin hole to the edge of the
member measured parallel to the direction of the force,
a b
a 39 mm
Limitting edge distance,
alimit 1.33 b e
3. Requirement 3: w 2be Dp
Width of plate at the pin hole measured in the direction normal to the applied force,
w Bpl if θmax = 0 deg
min Bpl h pl otherwise
w 100 mm
Limiting width,
wlimit 2 b e Dp
4. Requirement 4: c a
Distance from edge of the hole to the corner of the plate,
c
2 2
Lev Leh 15 mm cos θmax
c 60.104 mm a 39 mm
RESULT = Dimensional Requirement 4 is Satisfied, OK