Professional Documents
Culture Documents
b. positive voltage
c. photo voltaic
d. primary voltage
c. LED globe
d. halogen lamp
a. wind
b. solar
c. water
d. fossil fuel
4. you are looking at purchasing a new refrigerator for the home. You have noticed that new
refrigerators have an Energy rating system.
5. Ohm’s law states that the electrical current (I) flowing in a circuit is proportional to the voltage (V) and
inversely proportional to the resistance (R).
b. R = V× I
c. I = V × R
d. R = I/V
6. the 15-ohm heating elements in the circuit below become open circuited. The current in the circuit
would be;
22.5 Volts
15 Ω 15 Ω
c. the same
d. zero
7. you have been asked to replace the resistance network circuit (R2,R3,and R4) below with a single
resistor. R2
R1 40Ω
5Ω R3
40Ω
230 Volts
R4
2Ω
a, 20Ω
b. 27Ω
c. 40Ω
d. 87Ω
8. if the current in this circuit is 4 ampere. What is the voltage drop across R2?
4Ω 2Ω 1Ω
R1 R2 R3
a, 4V
b. 8V
c. 16V
d. 28V
9. which 0f the following devices depends upon an electromagnetic effect for its operation?
a. contractor
c. incandescent lamp
d. thermal overload
10. two inductors with inductive reactance of 0.16 ohm and 0.48 ohm are connected in a series.
0.16Ω 0.48Ω
a, 0.12Ω
b. 0.32Ω
c. 0.64Ω
d. 3.00Ω
11. if a.d.c. motor has an efficiency of 90% with an input rating of the motor is 8kW, what is the output
power of the motor?
a, 720W
b. 7.2 kW
c. 8kW
d. 9kW
12. what type of tester/meter is used to measure current in a circuit without actually connecting the
tester/meter into the circuit?
a, clamp meter
c. multimeter
d. neon tester
13. the RMS value of a sine wave with a peak (maximum) value of 10 volts a.c. is;
a, 5V
b. 6.3V
c. 7.07V
d. 10V
a, capacitive
b. inductive
c. reluctance
d. resistance
15. if you were given a capacitor to connect into fluorescent light fitting for power factor correction, to
which terminals would you connect a capacitor?
a, terminals 1 and 2
b. terminals A and N
c. terminals 7 and 8
d. terminals 5 and 6
16. you have been called out to replace a small electric boiler. When you arrive there is no nameplate on
the boiler, so you need to calculate the kW rating of the boiler. The boiler consists of three heating
elements each is 15 ohm and are connected in a star configuration to a 230/400V, 3-phase supply.
15Ω
15Ω 15 Ω
a, 1.8kW d. 10.58kW
b. 3.5kW
c. 6kW
17. what is the name of the device used in a refrigerator that automatically responds to temperature
changes?
a. simmerstat
b. thermostat
c. thermistor
d. thermometer
c. boost the voltage on starting and to limit current when the tube is working
19. you have been given four different types of batteries by a non electrical person and the person has
asked you which one of the batteries can he recharge.
c. mercury cell
20. there are two[2] types of smoke detectors? One type is photo electric . what is the name of the
other type? Choose from the list below.
a, mechanical type
b. Ionisation type
c. maintain type
Sec ……?.........Volts
a, 2V
b. 57.5V
c. 115V
d. 460V
22. what term is used to define the twisting and turning effect of a motor?
a. braking
b. rotor
c. speed
d. torque
23. which one of the following types of electric motor is not a Single phase type?
24. which one of the following formula expresses the relationship between synchronous speed [nsym]
poles [p] and frequency [f] of a three phase induction motor?
a,
b.
c.
d.