Professional Documents
Culture Documents
com
e-mail: info@fine-tek.com
ULTRASONIC LEVEL TRANSMITTER Tel: 886-2-22696789 Fax: 886-2-22686682
MAIN FUNCTIONS
2 Level measurement
2 Object distance measurement
2 Volume measurement
2 Differential level measurement
2 Pump control
1
APPLICATIONS
1. Water or waste water treatment equipment: for 4. Granular materials such as flour, rice, wheat and
instance, pump, open channel, dams and wells. corn.
2. Liquid such as edible-oils, sauces, diesel oils 5. Chemical fibers and petrochemical materials
and beverages. such as plastic powders, plastic granules and
3. Chemical material such as solvent, paints, plastic chips.
carbonic, water, crude oil, epoxy resin, lime
slurry and wax.
Up to 300M 4~20mA
PC or PLC
PM
Meter
PB/PM
Liquids panl meter
or
solids Recorder
Relay output Hi. Alarm
RS232
RS485
Lo. Alarm
DC24V
2
SPECIFICATIONS / DIMENSIONS
60mm A/F
Materials
Housing-glass Filled Nylon
Wetside-PVDF
3
INSTALLATION
2-wires (Power Supplied by panel meter) The ultrasonic transducer is mounted to the flange
of the extension neck of the tank. Please refer to
+24V
the instruction below:
DC24V
6" 150mm 400mm
Power Supply
8" 200mm 600mm
FineTek PI Meter
F G 12" 300mm 600mm
+24V
Iin
Com
L: Extension probe
H: Bin High
4-wire (PLC)
+24V
PLC
+24V
GND
Vin
Iin
Com
4
SET UP PROCEDURE
for>10s
Level
5
CAUTION BEFORE INSTALLATION
Keep the transducer perpendicular to the liquid The transducer should not be mounted too close to
surface. the tank wall to avoid interference caused by the
tank wall.
X X
A pipe surrounding the detection path along the Do not mount the device close to the tank wall in
ultrasonic wave from emitting to receiving is case the fake signal caused by the bracket.
recommended, thus installation can prevent fake
signal caused by turbulence and foam when
agitator is equipped in the tank. When the pipe is
installed, a vent hole is required to balance the
pressure difference between the inside and outside
of pipe..
vent hole
X
X
Mount the transducer away from the inlet to avoid When user mount the transducer on the solid tank,
interfere by medium. the transducer must point to the outlet of tank.
X X