Professional Documents
Culture Documents
Introduction:
Solar Charge Regulator is designed to control the charge from the solar panel into the battery and the
power drawn from the battery to outputs.
Main Features:
TPS-555 12V/TPS-555 24V Solar Charge Regulator is able to handle charge and discharge from
either 12V battery or 24V battery (Different Model required).
It provides over-charging, over-discharging and over-load protection. Therefore keeping the whole
solar system at proper working condition.
This solar charge regulator uses the latest Microcomputer-chip for peak performance.
PWM (pulse width modulation) charging circuit is used for higher efficiency.
Big LCD display for easy monitoring.
M4X20 Screws are advised when mounting regulator.
Technical data:
Solar panel
Battery +
Battery
DC Load +
DC Load
-
-
-
+
1. Use multi-strand insulated copper wire not less than Φ6mm2, bare strip 5mm at the end for
connection to the charge regulator. Make sure that all connections are secure and tight to reduce power
loss.
2. Battery should be connected to the port where shows “ ”. Please note that “+” stand for
positive pole, and “-” stands for negative pole. Make sure you connect with correct polarity.
3. DC load should be connected to the port where shows “ ” Please note that “+” stand for
positive pole, and “-” stands for negative pole. Make sure you connect with correct polarity.
4. Solar panel should be connected to the port where shows “ ” Please note that “+” stand for
positive pole, and “-” stands for negative pole. Make sure you connect with correct polarity.
5. Finally make sure that all connections are secure and correct.
How to disconnect and connect the charge regulator:
When connecting or disconnecting the charge regulator please follow the sequence below.
Disconnecting:
1. First disconnect the negative then the positive solar panel leads
2. Turn off “Load” on/off switch, then disconnect load.
3. Lastly disconnect the negative then the positive connections from battery do not disconnect battery
before disconnecting solar panel.
Connecting:
1. First connect regulator to battery, positive lead then negative lead
2. Then connect solar panel to regulator Positive lead then negative lead
3. Finally, connect any lights or 12V appliances (if any).
In order to make sure the regulator is working correctly please comply with the above mentioned
installation procedure.
The Display Shift Button works in a cycle pattern. By pressing the bottom, LCD will switch in
between the three different models as below.
Battery voltage
1. When using the solar system make sure that the voltage of battery and the voltage of the solar panel match.
The max power of the solar panel can be used for TPS-555 12V should be 360 W/12V, and for TPS-555 24V
should be 720W/24V.
2. Please do not touch clamps or any bare strip lead wire of solar panel to prevent the chance of electric shock.
3. Please cover the surface of solar panel during the installation process to prevent the chance of electric shock.
4. Input current from the solar panel should not exceed the Max solar input current limit of the regulator.
5. The charge regulator is NOT waterproof keep away from direct contact with rain or water.
6. Place the charge regulator in a cool ,dry ,ventilated position for safety purposes avoid direct sunlight, hot
surfaces, dust or moisture.
Trouble Shooting:
1. No output: Check load is connected correctly and secure. Check working current is within the Max output
current limit.
2. Will not charge: Check connection of the solar panel, battery and regulator is secure.
3. Current keeps changing: This situation is normal, and is due to the pulse width modulation method of
charging.