You are on page 1of 3

ConneXium Product data sheet

Unmanaged IP67 rated Ethernet Switch 5TX

Description
The ConneXium model TCSESU051F0 is a 5 Port Unmanaged Ethernet Switch in an IP67 rated watertight
enclosure that supports Ethernet 10 Mbit/s and Fast Ethernet 100 Mbit/s communications with 5 copper cable
connections(5TX). The Unmanaged Switches are low cost connectivity device that do not support the range of services
available in the managed switches

Features
> Low cost Ethernet switch

> Switch conforms to IP67 rated dustproof and watertight


protection\

> 5 Ports with M12 connectors supporting IEEE 802.3 and


802.3u copper cable technology

> Plug and Play operation – no configuration required

> Supports Unicast, Multicast, and Broadcast data types

> High speed Ethernet communication rate – 10/100 Mb


with auto sensing

> Auto-set half-duplex/full-duplex communication

> Auto crossing to detect cable wiring

> Built-in 24 VDC Power Supply with a 5 pin M12 connector

> Built-in LED Indicators for power and communications

> Mounting directly on equipment – no enclosure


required

> Operating temperature range 0° to +60° C


ConneXium Unmanaged Ethernet Switch Page 2

Overview
The ConneXium model TCSESU051F0 is a 5 port Unmanaged Switch in an IP67 rated dust proof,
watertight enclosure that is designed to be mounted directly on equipment without the need for an
enclosure. This switch includes 5 - M12 copper ports, that maintain the watertight rating,
supporting cable runs up to 100 meters.

The ConneXium model TCSESU053FN0 Unmanaged Switch is suited for small and simple
networks that do not carry critical network communications. This Unmanaged Switches does not
require any configuration prior to connection to the network.

Switch Capabilities
Store and Forward All data received is stored and checked for validity, all invalid frames
(greater than 1,522 bytes or with CRC errors) and frame fragments less
than 64 bytes) are discarded, and valid frames are forwarded.

Multi-Address Capability The switches learn source addresses on a per-port basis. Only packets with
these addresses in the destination address field are sent to the ports, a
switch can learn up to 1000 addresses.

TP/TX Interface Link Control


The switches monitor the connected copper cables segments for short
circuits and interrupts using regular link test pulses in accordance with IEEE
standard 802.3 for 10/100 base-T. The switches do not transmit data to
any segment without link test pulses.

Autopolarity Exchange
The switches automatically reverse polarity if the receive line pair is
incorrectly connected (when + and - are switched).

Autonegotiation
The switches automatically detect link communication speed (10 or 100
Mbit/s) and half-duplex/full-duplex communication port operation

Autocrossing
The switches detect the transmit and receive pairs (MDI, MDI-X), and
automatically configure each port for the correct transmit and receive pins.
This allows the use of either a crossover or straight cable.

Schneider Electric - All Rights Reserved


January 15, 2010
ConneXium Unmanaged Ethernet Switch Page 3

Technical Specifications
Supply Voltage 24 VDC
Operating Voltage Range 18 to 32 VDC
Hold up time Min 10 ms @ 24 VDC
Current Consumption 130mA max @ 24 VDC
Module Dimension 60mm W X 126mm H X 31mm D
(2.36 X 5 X 1.2 in.)
Weight 21g ( .46lbs)
Operating Temperature 0 to 60° C
Storage Temperature -25 to 70° C
Protection IP 67, according to EN 60529
Atmospheric Pressure Min. 79kPa
Shock and Vibration IEC 60068-2-6, IEC 60068-2-27
EMC EN55022 Class A, FCC 47 CFR part 15
Approvals UL 508
CSA 22.2 – 142
CE

Conformance RoHS Directive

LED Indicators Power Present


Data Rate (10/100Mbit/sec) - 1 per port
Data Link Status - 1 per port

MTBF 1,187,856 hr. at 25°C GB

Accessories
Cables Model Number Available Connector Type
Length(m)
Power Cables XZCP1164L• • = 2,5 Female M12, straight
XZCP1264L• • = 2,5 Female M12, elbow
Spare Power XZ-CC12FDM50B Female M12, straight
Connectors XZ-CC12FCM50B Female M12, elbow
Ethernet Cables TCSECL1M3M•S2 •= 1, 5, 10, M12(IP67) to RJ45
(terminated) 25, 40 (IP20)
TCSECL1M1M•S2 •= 1, 5, 10, M12 to M12
25, 40

Schneider Electric - All Rights Reserved


January 15, 2010

You might also like