Professional Documents
Culture Documents
Figure 1: Block diagram communication unit During initialization and operation the module carries
out a number of tests. If a fault occurs it is reported to
the communication unit. All fault conditions impairing the
Characteristics function of the module are displayed as common fault
signal by a red LED. A failure of the connected module(s)
is detected and signalized by the communication unit.
Communication unit
On the applied ARM cortex A9 controller AM437 a real-
Binary input unit
time operating system is implemented. The 530CID02
is responsible for the interface management, the event
handling, the time base and the internal data base. The I1
I01
controller acts as master for the serial RTU530 I/O bus I02
I2
(IOB). Micro- I03
controller I3
Input register
RTU530 I/O bus
RAM
embedded multi memory card in order to guarantee a valid
I05
system configuration after Power on Reset (PoR). Flash
I5
I06
I6
The communication unit provides the following interfaces: IOC
I07
• Communication Port 1 (CP1): a serial interface I7
Microcontroller
1 O01
Flash R01
C01
8
RAM O02
Data Bus
RTU530 I/O bus
5 V DC R02
C02
CPU
Voltage monitoring CMD O03
R03
UART V2 C03
Output relay control
O04
R04
C04
24VDC
The supply voltage for the coils of the relays (24 V DC)
is switched by an internal switching transistor and is
monitored internally before and during the command
output.
Ordering information
530CID02 R0002 1KGT050900R0002
P.O. Box 42 01 30 document without prior notice. With regard Any reproduction, disclosure to third parties or for a Hitachi Energy company.
68280 Mannheim, Germany to purchase orders, the agreed particulars utilization of its contents – in whole or in parts – is
shall prevail. Hitachi Energy does not accept forbidden without prior written consent of Hitachi
any responsibility whatsoever for potential Energy.
errors or possible lack of information in this © 2022 Hitachi Energy
hitachienergy.com/rtu document. All rights reserved