Supported Device/Footprints Adapter Wiring This programmer supports programming several members of the The following chart shows the connections from the PLCC device Motorola 68HC11E9 family. They must be in a 52 pin PLCC to the adapter’s DIP plug. package. DEVICE SIGNAL PLUG The adapter plugs into the 32 pin BOOT MODE footprint 1 GND 14 established by Motorola and Logical Systems. 2 GND 14 3 GND 14 Adapter Dimensions 4 D6 22 5 N/C - 6 D7 23 7 EXTAL 18 8 N/C - 9 A0 10 10 A1 9 11 A2 8 12 A3 7 13 A4 6 14 A5 5 15 A6 4 16 A7 3 17 RST- 16 18 VPP 1 19 CE- 24 20 RX/D0 15/11 21 TX/D1 16/12 22 D2 13 23 D3 19 24 D4 20 25 D5 21 Adapter Construction 26 VCC 32 27 GND 14 The adapter is made up of 2 sub-assemblies. They assemble via 28 N/C - connectors making the adapter modular. This way the sub- 29 N/C - assemblies can be replaced when they wear out. When 30 N/C - disassembling the adapter take care not to bend the pins. When 31 GND 14 reassembling the adapter note the pin 1 indicators to align the 32 GND 14 parts correctly. 33 GND 14 34 GND 14 Test Socket 35 OE- 26 36 A14 31 PLCC test socket: 37 A13 30 Yamaichi Part #: IC120-0524-207 38 A12 2 39 A11 27 Note: This is a Dead-Bug socket, 40 A10 25 the device inserts with the pins up. 41 A9 28 42 A8 29 E20-52 43 GND 14 Accepts the test socket and performs the wiring shown in the 44 GND 14 Adapter Wiring section. 45 GND 14 46 GND 14 47 GND 14 Memory Access 48 GND 14 49 GND 14 Address Size '711E9 27C256 50 GND 14 51 GND 14 programmer 52 GND 14 D000-FFFF 12K Bytes EPROM Pgm/Read/Write 1000-3FFF 103F 1 Byte EEPROM No Access