Professional Documents
Culture Documents
Desarmado y Armado
3612 and 3616 Engines
Número de medio -SENR3594-12 Fecha de publicación -01/08/2008 Fecha de actualización -05/08/2008
i02419491
Disassembly Procedure
Table 1
Required Tool
Tool Part Number Part Description Qty
1H-3107 Bearing Puller 1
A
0S-1619 Bolt 2
B 1P-0510 Driver Gp 1
Start By:
A. Remove the engine oil pump. Refer to Disassembly and Assembly, "Engine Oil Pump -
Remove".
NOTICE
Keep all parts clean from contaminants.
1. Thoroughly clean the outside of the engine oil pump. Disassemble the engine oil pump in a
clean area.
Ver imagen
https://sis.cat.com/sisweb/sisweb/techdoc/content.jsp?calledpage=/sisweb/sisweb/med... 13/02/2010
Service Information System Página 2 de 4
Illustration 1 g00550544
2. Remove cover (1) and cover (2) from the back of the engine oil pump.
3. Place the engine oil pump in an upright position. The gears should face upward.
Ver imagen
Illustration 2 g00628384
4. Remove drive gear (3). This gear drives the fuel transfer pump.
5. Loosen bolt (4) from gear (5) until the washer is 3.20 mm (0.126 inch) from the gear.
6. Install Tooling (A). Tighten the screw in Tooling (A). Tap Tooling (A) over the shaft in order
to loosen the gear from the shaft. Remove Tooling (A) and gear (5) .
Ver imagen
https://sis.cat.com/sisweb/sisweb/techdoc/content.jsp?calledpage=/sisweb/sisweb/med... 13/02/2010
Service Information System Página 3 de 4
Illustration 3 g00550546
7. Remove cover (6). Note the location of the dowel in the cover. If necessary, remove the dowel.
Ver imagen
Illustration 4 g00550614
Note: The bearing in the Illustration has an internal groove. New bearings for the engine oil
pump will not have an internal groove.
8. If necessary, use Tooling (B) in order to remove bearings (7) from cover (6). If necessary,
remove the dowels from the opposite side of cover (6) .
Ver imagen
https://sis.cat.com/sisweb/sisweb/techdoc/content.jsp?calledpage=/sisweb/sisweb/med... 13/02/2010
Service Information System Página 4 de 4
Illustration 5 g00550615
Copyright 1993 - 2010 Caterpillar Inc. Sat Feb 13 17:57:28 EST 2010
Todos los derechos reservados.
Red privada para licenciados del SIS.
https://sis.cat.com/sisweb/sisweb/techdoc/content.jsp?calledpage=/sisweb/sisweb/med... 13/02/2010