Professional Documents
Culture Documents
&UDQH6\VWHPV
5&,
',63/$<&+$1*(287
6(59,&(%8//(7,1
*5((5&203$1< 1918 E. Glenwood Place, Santa Ana, CA 92705 Telephone: (714) 259-9702 Fax: (714) 259-7626
Service Information Bulletin
Owner: Greer Service Dept. Page 1 of 8 PN W450191 Rev C 07/30/01
*UHHU&RPSDQ\
&UDQH6\VWHPV
5&,',63/$<&+$1*(287
7DEOHRI&RQWHQWV
PART 1. Changing out the Display (In Dash version) ......................................................................3
*5((5&203$1< 1918 E. Glenwood Place, Santa Ana, CA 92705 Telephone: (714) 259-9702 Fax: (714) 259-7626
Service Information Bulletin
Owner: Greer Service Dept. Page 2 of 8 PN W450191 Rev C 07/30/01
*UHHU&RPSDQ\
&UDQH6\VWHPV
3$57
3$57
&+$1*,1*2877+(',63/$<
&+$1*,1*2877+(',63/$<
63/$<
,1'$6+9(56,21
,1'$6+9(56,21
Refer to Figure 1. Turn off all power to the computer unit.
Loosen fasteners and remove the inspection cover at the
top of the dash.
Fig. 1
Fig. 2
Refer to Figure 3. Insert the RCI 510 display through the
P065602 molded flange (thin side down) and insert the
RCI 510 display into the dash.
*5((5&203$1< 1918 E. Glenwood Place, Santa Ana, CA 92705 Telephone: (714) 259-9702 Fax: (714) 259-7626
Service Information Bulletin
Owner: Greer Service Dept. Page 3 of 8 PN W450191 Rev C 07/30/01
*UHHU&RPSDQ\
&UDQH6\VWHPV
3$57
3$57
&+$1*,1*2877+(',63/$<
&+$1*,1*2877+(',63/$<21
3/$<21'$6+9(56,21
21'$6+9(56,21
'$6+9(56,21
1. Turn off all power to the computer unit. Loosen mounting bracket knobs on the RCI 500 display.
Remove the display cable connector at the rear of the RCI 500 display. Remove the display for return
to Greer Company.
2. Remove the attaching bolts holding the mounting bracket to the dash of the unit. Remove the existing
mounting bracket and replace with the RCI 510 mounting bracket.
3. Install the knobs onto the studs on the RCI 510 display and insert the display into the bracket. Tighten
the knobs to retain the display.
4. Refer to Figure. 5 below. Reconnect the original display cable into the receptacle on the rear of the
RCI 510 display and tighten the nut.
Knob
Knob
Mounting Bracket
Fig. 5
*5((5&203$1< 1918 E. Glenwood Place, Santa Ana, CA 92705 Telephone: (714) 259-9702 Fax: (714) 259-7626
Service Information Bulletin
Owner: Greer Service Dept. Page 4 of 8 PN W450191 Rev C 07/30/01
*UHHU&RPSDQ\
&UDQH6\VWHPV
3$57
$57
&+$1*,1*&+,36$65(48,5('
&+$1*,1*&+,36$65(48,5('
(48,5('
1. Refer to Figure. 6. Loosen and remove the four screws at
the corners of the computer box while carefully supporting
the lid of the box to keep it from falling and damaging
components on the top computer board.
2. Lift the lid from the box and put lid away for reinstallation.
3$57CONTINUED.
&+$1*,1*&+,36$65(48,5('
&+$1*,1*&+,36$65(48,5('
(48,5('
1. Refer to Figure. 8. Before seating the chip, make sure that the notch on the chip is pointed in the
proper direction.
2. Replace the lid on computer box and carefully tighten the screws, rotating from the corner to
assure the cover is tightened uniformly.
Notch
*5((5&203$1< 1918 E. Glenwood Place, Santa Ana, CA 92705 Telephone: (714) 259-9702 Fax: (714) 259-7626
Service Information Bulletin
Owner: Greer Service Dept. Page 6 of 8 PN W450191 Rev C 07/30/01
*UHHU&RPSDQ\
&UDQH6\VWHPV
3$57
$57
21,1,7,$/67$5783
21,1,7,$/67$5783
1. Start unit and wait for computer startup instruction screen. Follow instructions on screen to
proceed to main setup screen.
2. Refer to Figure 9. The set button will immediately illuminate and the audio alarm will sound. The
screen for the operator alarms will appear as shown.
3. Refer to the operator’s manual (pages. 26-31) for instructions on canceling and resetting opera-
tor alarms as needed.
4. Refer to Figure 10. This Figure shows what the alarms look like when improperly set. Push the
set button and turn the alarms off one at a time until all operator alarms are off.
*5((5&203$1< 1918 E. Glenwood Place, Santa Ana, CA 92705 Telephone: (714) 259-9702 Fax: (714) 259-7626
Service Information Bulletin
Owner: Greer Service Dept. Page 7 of 8 PN W450191 Rev C 07/30/01
*UHHU&RPSDQ\
&UDQH6\VWHPV
*5((5&203$1< 1918 E. Glenwood Place, Santa Ana, CA 92705 Telephone: (714) 259-9702 Fax: (714) 259-7626
Service Information Bulletin
Owner: Greer Service Dept. Page 8 of 8 PN W450191 Rev C 07/30/01