Professional Documents
Culture Documents
Dry battery initial charging SOP蓄电池初充电工艺要求
Dry battery initial charging SOP蓄电池初充电工艺要求
1、首先取下每只电池的注液盖(电池上的黄色盖子)
,加入比重为 1.265 左右的蓄电池用稀硫
酸溶液,确保每只电池都要加上酸后,盖好黄色注液盖,用清水清洗干净电池表面酸液,
(注
意不要把用来清洗电池的水流入电池内部)静止 3-4 小时后,可以开始充电了。但不得超过
12 小时.
1. Firstly remove the liquid injection cap (yellow cap on the battery) of each battery cell, and
add dilute sulfuric acid solution for the battery with a specific gravity of about 1.265. Make
sure that each battery is filled with acid properly, and then cover the yellow liquid injection
cap. Rinse the acid on the surface of the battery with clean water. (Be careful not to let the
water mix into the battery cell.) After standing for 3-4 hours, you can start to charge the
battery. But do not wait for more than 12 hours.
2、首先要确认电池的正极接充电机的正极,电池的负极接充电机负极正确接好,充电分两个
阶,首先用 60A 电流充 10 小时,转入第二阶段,用 30A 电流充 60 小时,就可结束。
2. Before charging, it is necessary to confirm that the positive pole of the battery is
connected to the positive pole of the charger, and the negative pole of the battery is
connected to the negative pole of the charger correctly. First stage, the 60A current is
used to charge for 10 hours. Second stage, the 30A current is used to charge for 60 hours.
Then complete the initial charging process.
3、充电过程中的注意事项 Caution during charging