Professional Documents
Culture Documents
com
800-241-1806
Typical Usage:
Guardrail systems can be used around roof openings and
at the roof perimeter. Identifying the most common rooftop
safety hazards and providing safety training to workers is
imperative to ensure a safe workplace.
OSHA Compliance:
New OSHA Rule in affect: Walking-Working Surfaces,
1910.28, please consult this as well as all local, State and
Federal OSHA rules
Zip Base #70756
Features: 3 hole base, yellow powder coat with rubber feet
• Used as a portable or permanent guardrail (58 lbs). Nests and stacks easily for storage
• Quick easy installation before and after use. Comes with toe board slots
• No drilling or tools needed on each side and handle holes for lifting.
• High Visibility TS22 Safety Paint and Pre-galvanized
tubes available
• EPDM rubber pads for added roof surface protection
• 5, 7.5 & 10 feet guardrail sizes
Minimum Requirements:
Guardrail Outriggers MUST be used at both ends of any
interruption in continuous guardrail sections, or at both
NEW!
ends of a continuous guardrail section.
• Molded
• Soft Rubber Feet
Use on Low Slopped Roofs
• Rivet Option
The Universal Guardrail can be used on a low slopped
roof up to a 2/12 pitch. An additional 5 ft. rail and
guardrail base, outrigger, must be placed every 20 ft.
404-344-0000 • tiedown.com
605 Stonehill Drive SW, Atlanta, GA 30336
roofing@tiedown.com
www.tiedown.com
800-241-1806
Railings: Finishes:
High Strength Low Alloy (HSLA) Steel 1.66" (42 mm) O.D. Available in High Visibility TS22 Safety Paint,
HRPO electric weld tubing, free of sharp edges and Pre-galvanized tube, and custom colors upon request.
snag points.
10 ft.
(#70758/#70764)
4.91”
7.5 ft.
(#70759/#70765)
29.1”
5 ft.
(#70760/#70766)
3.42”
3.83”
14.5”
5 ft. “D” Rail
3.83”
(#70778)
2.13”
14.5”
5 ft. Gate
10.0” (#70776)
Guardrail
Installation
Instructions
404-344-0000 • tiedown.com
605 Stonehill Drive SW, Atlanta, GA 30336
roofing@tiedown.com