Professional Documents
Culture Documents
COLLEGE OF ENGINERING
AND TECHNOLOGY
DEPARTMENT OF MECHANICAL
ENGINERING
Advanced fluid mechanics ASSIGNMENT
II
validate the result using ANSYS(Fluent) in order to make sure that makes a sense.
a) Geometry modelling
b) The mesh
c) Set up
d) Xy plots of velocity and pressure
e) Wall Yplus vs position
f) The Cfd posts
- velocity stream lines
- contour lines
- streak lines
-velocity vectors
Submit the final result in the form of soft copy either in pdf/doc.
NOTE: - This assignment is given for both cep ad regular class students
Under Advanced Geometry Options for Analysis Type select 2D.
Mesh Generation:
Double click on Mesh from the Fluid Flow System in the project
schematic. Keep theMeshing Options defaults.
Verify metric units are used (meters, kilograms, Newtons, etc.).
That can be done byselecting units.
Do the same for the rest of the edges, naming the left one inlet, the
right one outlet, andthe bottom one axis.
Meshing can now be closed and it will automatically be saved.
Save the project by selecting File-Save As
Problem Setup: