Professional Documents
Culture Documents
Components (Cont’d)
CAUTION:
+ When installing camshafts, chain tensioners, oil seals, or
other sliding parts, lubricate contacting surfaces with new
engine oil.
+ Apply new engine oil to threads and seat surfaces when
installing cylinder head, camshaft sprocket, crankshaft
pulley, and camshaft bracket.
+ Attach tags to valve lifters so as not to mix them up.
Removal NJEM0063
PREPARATIVE WORK NJEM0063S01
1. Drain engine coolant. Refer to LC-43, “Changing Engine Cool-
ant”.
2. Remove exhaust manifold. Refer to EM-111, “Removal”.
3. Remove intake manifold. Refer to EM-107, “Removal”.
+ Apply paint to camshaft sprockets for alignment during
installation.
CAMSHAFT NJEM0063S02
1. Remove the following parts:
+ Rocker cover
+ Vacuum pump and cylinder head rear cover assembly
+ Spill tube
+ High pressure injection nozzle assembly
+ Secondary timing chain and associated parts
JEM152G
JEM159G
3. Remove camshafts.
+ Loosen bolts holding the camshaft bracket in several stages in
the reverse order of that shown in the figure, and remove them.
4. Remove adjusting shims and valve lifters.
+ Confirm the correct location of each part removed. Store them
so they do not get mixed up.
+ For re-installation, be sure to put mark on camshaft
bracket before removal.
JEM160G
EM-119