Professional Documents
Culture Documents
ELECTRICAL SPECIFICATIONS
Voltage Capacity A Amp-Hours (Ah) Energy kWh Internal Resistance (mΩ) Short Circuit Current (A)
10-Hr 20-Hr 48-Hr 72-Hr 100-Hr 20-Hr
12V 4.80 2555
94 105 109 111 113 1.26
CHARGING INSTRUCTIONS
Charger Voltage Settings (at 77°F/25°C)
0.005 volt per cell for every 1°C below 25°C 0.005 volt per cell for every 1°C above 25°C 100 2.14 12.84
0.0028 volt per cell for every 1°F below 77°F 0.0028 volt per cell for every 1°F above 77°F
75 2.09 12.54
4500 120 50
4000 100
40
3500 30
80
Temperature (C)
(F)
Temperature (F)
Temperature (C)
3000 20
Number of Cycles
Temperature
60
2500 10
40
2000 0
20
1500 -10
0
1000 -20
0 -40 -40
0% 20% 40% 60% 80% 100% 0% 20% 40% 60% 80% 100% 120%
7 6 5 4 7 3 6 2 5 1 4 3 2
100.0
ZONE DESCRIPTION ZONE REV DATE DESCRIPTION
NOTES: UNLESS OTHERWISE SPECIFIED NOTES: UNLESS OTHERWISE SPECIFIED
10°C (50°F) INITIAL RELEASE; COR5928
INITIAL RELEASE; COR5928 A 3/15/17
80 2.10
Recharge Threshold @ 75% SOC
75 H 2.09 H
1. ALL DIMENSIONS ARE NOMINAL. 1. ALL DIMENSIONS ARE NOMINAL.
60 2.06
25°C (77°F)
Time (hrs)
10.0
G G G
40 40°C (104°F) 2.02
30°C (86°F)
20 1.98
F F
1.0
0 1.94
0 2 4 6 8 10 12 14 16 1 10 100
BATTERY DIMENSIONS E
7 6 5 4
E
3 2
Dimensions Inches (mm) - shown with M8 , height is 10.19 (259) with LT NOTES: UNLESS OTHERWISE SPECIFIED
ZONE DESCRIPTION
SCALE 0.500 SCALE 0.500 INITIAL RELEASE; COR5928
H
1. ALL DIMENSIONS ARE NOMINAL.
12.80 (325) 2. HEAT SEAL MELT = 0.100"12.80 (325)
6.81 (173) 6.81 (173)
LENGTH
D LENGTH WIDTH
WIDTH D
SCALE 0.400
B
B
E
WHICH SHALL NOT BE COPIED,
REPRODUCED DISCLOSED TO
OTHERS OR USED IN WHOLE OR
PART FOR ANY PURPOSE WITHOUT
THE EXPRESS WRITTEN
PERMISSION OF TROJAN BATTERY
CO. THIS DRAWING IS LOANED IN
CONFIDENCE WITH THE 12380 C
12380 CLARK ST. SANTA FE SPRINGS, CA 90670
UNDERSTANDING THAT IT SHALL
SCALE 0.500 5194 MINOLA DR. LITHONIA, GA 30038 5194 MIN
BE RETURNED ON DEMAND
SPECIFICED SPECIFICED
TOLERANCES ARE:
(SKIRT DESIGN) TOLERANCES ARE:
DWN B
X.X
X.XX
0.1"
0.05"
DWN BY
A. SAN SCALE CHK APPVD
CSIZE=DWG SCALE
X.X
X.XX
0.1"
0.05"
12.80 (325)
X.XXX 0.02" DATE
6.81 (173)
X.XXX 0.02" DATE DWG NO REV
7 6 5 3/15/17 721137 4 A 3
ANGLES = 2
7 6 5 4 3
ANGLES = 2
D LENGTH WIDTH
Confidential Information of Trojan Battery Company, LLC. Confidential Information of Trojan Battery Company, LLC.
All unauthorized use, disclosure or distribution is prohibited. All unauthorized use, disclosure or distribution is prohibited. SC
Controlled document; user is responsible for verifying revision is current prior to use. Controlled document; user is responsible for verifying revision is current prior to use.
D
TERMINAL CONFIGURATIONS
C *SAME OVERAL
M8 M8 with LT Adapter (adapter provided but not installed) FOR G31 12V/6
8.69 (221)
M8 x 1.25
5194 MINOLA DR. L
SPECIFICED
TOLERANCES ARE:
X.X
X.XX
0.1"
0.05"
DWN BY
A. S
X.XXX 0.02" DATE
7 6 5 4 3
ANGLES = 2
3/15/
A. The amount of amp-hours (Ah) a battery can deliver when discharged at a constant rate at 86°F (30°C) for all rates and maintain a C. Height taken from bottom of the battery to the highest point on the battery. Heights may vary depending on type of terminal.
Confidential Information of Trojan Battery Company, LLC.
voltage above 1.75 V/cell. Capacities are based on peak performance. D. Terminal images are representative only.
All unauthorized use, disclosure or distribution is prohibited.
Controlled document; user is responsible for verifying revision is current prior to use.
B. Dimensions may vary depending on type of handle or terminal. Batteries should be mounted with 0.5 inches (12.7 mm) spacing E. A boost charge should be performed every 6 months when batteries are in storage.
minimum. F. Weight may vary.
© 2018 Trojan Battery Company, LLC. All rights reserved. Trojan Battery Company is not liable for damages that may result from any information provided in or omitted from this publication, under any circumstances. Trojan Battery Company reserves the right to make adjustments to this
publication at any time, without notice or obligation.