Professional Documents
Culture Documents
Eas Display Parameters
Eas Display Parameters
Value To Be
Parameter Descriptions Entered(from Kaym 92-
# Hamit) PD
0 This parameter must be " 0 " 1 0
It shows decimal section of measurement value,
1 on the screen 2 2
It shows direction of counting . " 0 " is normal,
2 " 1" is opposite direction 0 1
3 Coefficient of Calibration 0.03 0.05
4 This parameter must be " 0 " 0 0
5 Slowdown Value of positive direction 3 6
6 Slowdown Value of negative direction 3 6
7 Lethargy Value of positive direction 0 6
8 Lethargy Value of negative direction 0 6
9 Distance of passing target value 0.03 0.5
10 Choosing to type of positioning 1 1
11 Lethargy Selection 1 1
12 This value must be " 0 " 0 0
13 Referance Value 96.9
14 First output time 0 0
15 Second output time 0 0
16 Knife Delay Time 6 8
17 Fourth output time 0 0
18 Fifth output time 0 0
19 Positioning Tolorance 0.01 0.01
20 Limit switch of negative direction -999 -999
21 Limit switch of positive direction 999 999
22 Earning coefficient 80 50
23 Front driving value at the end of the programme 5 5
24 Speed of go to referance 500 300
Send to referance.