Professional Documents
Culture Documents
The burner faults can be diagnosed by looking at the indicator light on the control box.
The burner faults can be diagnosed by looking at the digital display on the control box. The burner controller
lockout codes for PME840 are as follows:
This display is possible in standby mode or operating mode by pressing the + button on the LME7 see below:
This will then display the flame signal current as a percentage: see flame sense percentage reference chart
below:
Flame sense signal can also be viewed on the AZL Display units by pressing down the ‘reset’ button twice to
get to ‘service level’ once here scroll to parameter 954 ‘flame intensity’ this will then appear as a percentage
The burner phase is displayed on the digital display of the burner controller. The burner controller phase list
(state the burner controller is in) is displayed below