Professional Documents
Culture Documents
Millipore - A10 AND A-11 UV REPLACEMENT PDF
Millipore - A10 AND A-11 UV REPLACEMENT PDF
Tlie complete changeout of this UV lamp involves the physical removal and replacement of the lamp and then a reset of a
software timer. Tlie softwaretimer is simply reset to 365 calendar days.
5. Locate the A-IO device (also referred to as an A-11). It Is located inside the Milll-Q behind the Quantum
P u r i fi c a t i o n P a c k .
It Is a PCUoard which Is mounted vertically and has pieces of tubing eoming to and from it.
6. Place your hand on the top of the A-IO and pull it about 2-3 cm forward. (X) NOT null on the A-IO where the
7. Use a flat ended screwdriver and remove the two stainless steel clips that hold the black chamber to the A-IO
device.
10. Place tlie two sUilnless steel clips back on the A-IO.
11. Put the system cover back on. Plug in the power cord. Turn on the power.
S T A N D B Y
S t a n I n S TA N D B Y m o d e .
If you do not see the display above (SERVICE VALUES), then turn off the power. Turn on the power and proeccd again from
S TA N D B Y m o d e .
P E 0 9 I 11 R e v. - 0 9 / 0 3
4 1