Two long cylinders of different materials but the same diameter have one end attached to a 100°C base and the other exposed to 20°C air. A thermocouple measured the temperatures along the cylinders, finding rod A reached 20°C at 0.15m from the base, and rod B at 0.075m. Given the thermal conductivity of rod A is 70 W/mK, the problem asks to determine the thermal conductivity of rod B.
Two long cylinders of different materials but the same diameter have one end attached to a 100°C base and the other exposed to 20°C air. A thermocouple measured the temperatures along the cylinders, finding rod A reached 20°C at 0.15m from the base, and rod B at 0.075m. Given the thermal conductivity of rod A is 70 W/mK, the problem asks to determine the thermal conductivity of rod B.
Two long cylinders of different materials but the same diameter have one end attached to a 100°C base and the other exposed to 20°C air. A thermocouple measured the temperatures along the cylinders, finding rod A reached 20°C at 0.15m from the base, and rod B at 0.075m. Given the thermal conductivity of rod A is 70 W/mK, the problem asks to determine the thermal conductivity of rod B.
Consider two long, cylinder rods of the same diameter but different
materials. One end of each rod is attached to a base surface
maintained at 100 ℃ while the surface of the rods are exposed to ambient air at 20 ℃ . By traversing the length of each rod with a thermocouple, it was observed that the temperature of the rods were equal at the positions X A =0.15 m and X B=0.075m where X is measured from the base surface. If the thermal conductivity of rod A is known to be K A =70 W /m. K , determine the value of K B for rod B. - What is meant by heat transfer? - What are the Types (Modes) of Heat Transfer Processes? - Define each mode with its formulas. b) Write down the general Heat Diffusion Conduction in 3-D Transient with Heat Generation in Cartesian Form, then for a plane wall 1-D steady-state conduction without heat generation, prove that the thermal resistance for conduction
c) Drive the critical radius of insulation formula (ro cr ). Explain the
relation between (ro, ro cr) & its applications in heat transfer with drawing? For minimum q ' or maximum R'tot :