Professional Documents
Culture Documents
Universiti Teknologi Malaysia Faculty of Education Test 1 (Retest) Semester Ii Session 2008/2009
Universiti Teknologi Malaysia Faculty of Education Test 1 (Retest) Semester Ii Session 2008/2009
SPL 1012
UNIVERSITI TEKNOLOGI MALAYSIA FACULTY OF EDUCATION TEST 1 (RETEST) SEMESTER II SESSION 2008/2009
BASIC ELECTRIC AND ELECTRONIC One hour and thirty minutes
DO NOT OPEN THIS QUESTION PAPER UNTIL YOU ARE TOLD TO DO SO 1. 2. 3. Write your name, I/C number and course at the top right hand corner of your OMR form. Write the name of your lecturer at the top left hand corner of the OMR form. You are not allowed to leave the examination hall during the last 15 minutes of the examination time.
WARNING:
Disciplinary action will be taken against students who are found cheating during the examination. This question paper consists of 4 printed pages
SPL 1012
CONFIDENTIAL
CONFIDENTIAL
Question 1 (20 Marks)
SPL 1012
Figure 1.0 showed a simple circuit of controllable speed motor. The maximum resistance value of R is 5k. In other hand, internal resistance for DC motor far smaller than R which is 100. The relationship between motor speed and resistance value of point a and point c, Rac is showed by Table 1.0
b IM R c a M
i) Calculate voltage across point a and point c, Vac by using Figure 1.0 and Table 1.0 for each of the speed. (5M) ii) Calculate IM that flowing to DC motor for each of the speed. (5M) iii) Draw IM-Speed curve by using answer in i) and ii). (5M) iv) Explain the relationship between IM and speed of motor and give one daily application that uses the same concept in Figure 1.0. (5M)
SPL 1012
CONFIDENTIAL
CONFIDENTIAL
Question 2 (15 Marks) IS = 72mA R1 48V R2
SPL 1012
40mA
VS
12mA
RL1 = 1.6k
Figure 2.0 Given the voltage divider of Figure 2.0: i) Determine the supply voltage, VS. ii) Find the load resistor RL2 and RL3. iii) Calculate the power dissipated by RL1, RL2 and RL3. (5M) (4M) (6M)
SPL 1012
CONFIDENTIAL
CONFIDENTIAL
Question 3 (15 Marks)
SPL 1012
R1 A 18
R2 18
R3 18
VS1 = 30V
VS2 = 20V
Figure 3.0 Figure 3.0 demonstrated a two voltage source connected in apposite polarity, i) Determine the total resistance, RT. (5M) ii) Find out I2 that flowing from point B to A. (2M) iii) Power dissipated by R3. (3M) iv) If R1, R2, and R3 are replace by three bulbs, which have the same value of internal resistance. What happen to two others bulb if one of the bulb is burn out and give a reason. (5M)
SPL 1012
CONFIDENTIAL