Professional Documents
Culture Documents
)1A single-phase full bridge diode rectifier circuit converts what type of voltage to what type of voltage?
a) AC voltage to DC voltage
b) DC voltage to AC voltage
c) DC voltage to DC voltage
)2What is the maximum output voltage of a single-phase full bridge diode rectifier circuit?
)3What is the advantage of using a single-phase full bridge diode rectifier circuit over a half-wave
rectifier circuit?
c) Higher efficiency
)4What is the output frequency of a single-phase full bridge diode rectifier circuit?
)6What is the purpose of the filter capacitor in a single-phase full bridge diode rectifier circuit?
)7What happens if one of the diodes in a single-phase full bridge diode rectifier circuit fails open?
)8What is the advantage of using a transformer in a single-phase full bridge diode rectifier circuit?
c) Low efficiency
)10Which of the following is a commonly used topology for a single-phase full bridge diode rectifier
circuit?
a) Graetz bridge
b) Half-bridge
c) Full-bridge
d) Buck-boost
A single-phase full bridge diode rectifier is supplied from 230v , 50 .Hz source . The load consists of R=10
ohm and a large inductance so as to render the load current constant.
Questions -:
)1What is the RMS value of the input voltage to the full bridge diode rectifier?
a) 230V
b) 325V
c) 162.5V
d) 115V
)2What is the peak value of the input voltage to the full bridge diode rectifier?
a) 230V
b) 325V
c) 162.5V
d) 115V
)3What is the frequency of the output voltage of the full bridge diode rectifier?
a) 50Hz
b) 100Hz
c) 150Hz
d) 200Hz
)4What is the maximum output voltage of the full bridge diode rectifier?
a) 230V
b) 325V
c) 460V
d) 650V
)5What is the minimum output voltage of the full bridge diode rectifier?
a) 0V
b) 115V
c) -115V
d) -230V
)6What is the output voltage ripple frequency of the full bridge diode rectifier?
a) 50Hz
b) 100Hz
c) 150Hz
d) 200Hz
)7What is the output voltage ripple magnitude of the full bridge diode rectifier if the load current is 1A?
a) 5.5V
b) 6.5V
c) 7.5V
d) 8.5V
)8What is the output power delivered to the load if the load current is 1A?
a) 23W
b) 32.5W
c) 46W
d) 65W
)9What is the efficiency of the full bridge diode rectifier if the output power delivered to the load is
23W?
a) 78.3%
b) 83.5%
c) 87.6%
d) 91.2%
)10What is the purpose of the large inductance in the load of the full bridge diode rectifier?
Questions-:
)1What is the peak voltage of the center-tapped secondary of the transformer in a single-phase full wave
center tapped uncontrolled rectifier with a supply voltage of 110V and 50Hz?
a) 77.5V
b) 110V
c) 155V
d) 220V
)2What is the peak-to-peak ripple voltage across the load resistor in a single-phase full wave center
tapped uncontrolled rectifier with a supply voltage of 110V and 50Hz?
a) 25V
b) 35V
c) 50V
d) 70V
)3What is the RMS voltage across the load resistor in a single-phase full wave center tapped uncontrolled
rectifier with a supply voltage of 110V and 50Hz?
a) 25V
b) 35V
c) 50V
d) 70V
)4What is the average voltage across the load resistor in a single-phase full wave center tapped
uncontrolled rectifier with a supply voltage of 110V and 50Hz?
a) 19.6V
b) 27.5V
c) 39.2V
d) 55V
)5What is the output power of a single-phase full wave center tapped uncontrolled rectifier with a
supply voltage of 110V and 50Hz, and a load resistor of 25Ω?
a) 484W
b) 625W
c) 781W
d) 1100W
)6What is the efficiency of a single-phase full wave center tapped uncontrolled rectifier with a supply
voltage of 110V and 50Hz, and a load resistor of 25Ω, if the output power is 625W?
a) 35.5%
b) 50%
c) 70.5%
d) 85.5%
)7What is the peak inverse voltage (PIV) rating of each diode in a single-phase full wave center tapped
uncontrolled rectifier with a supply voltage of 110V and 50Hz?
a) 55V
b) 77.5V
c) 110V
d) 155V
)8What is the purpose of the center-tapped transformer in a single-phase full wave center tapped
uncontrolled rectifier?
Answer: C
2- a single phase half wave rectifier circuit has freewheeling diode; the freewheeling diode conduct only
if.................................
Answer: d
Fig (1)
3) in the circuit shown in Fig (1), the effect of diode called …..............and it prevents the output voltage
from becoming …...............
Answer: C
4)in Fig (1), for negative half cycle, D1 is..............................and D2 is.....................
a) ON, OFF
b) OFF, ON
c)ON,ON
d)OFF, OFF
Answer: B