Professional Documents
Culture Documents
T650 Fuse and Relay
T650 Fuse and Relay
Description
P100958A
1
P109636 P107513A
The loader has a 12 volt, negative earth, alternator The electrical system is protected from overload by fuses
charging system. located under the fuse panel cover (Item 1) [Figure 242].
Remove the fuse panel cover by pulling at each end.
The electrical system is protected by fuses located in the
operator cab and a 100 ampere master fuse (Inset) A decal located on the fuse panel cover indicates fuse
[Figure 240] located above the battery in the engine and relay location and fuse amperage ratings.
compartment.
Figure 243
The fuses will protect the electrical system when there is
an electrical overload. The reason for the overload must 1
be found before starting the engine again.
Figure 241
1
P109659
Line up the clips on the back of the fuse panel cover with
the slots (Item 1) [Figure 243] in the fuse panel and push
the cover into position when finished.
Figure 244
NA3311
The table below is for earlier models with decal part number 7218779. Fuse location and amperage ratings are shown
in the table below and on the decal [Figure 244]. Relays are identified by the letter “R” in the AMP column.
ITEM ICON DESCRIPTION AMP ITEM ICON DESCRIPTION AMP ITEM ICON DESCRIPTION AMP
Cab Switched
F1 Rear Lights 15 F14 5 A Switched Power R
Power
Drive Controller
F4 Heater / HVAC 25 F17 25 D Traction R
Back-up Alarm
Switched Power
F5 25 F18 Attachments 25 E Rear Lights R
Back-up Alarm
Cab Switched
F8 25 F21 Engine Controller 15 H Not Used --
Power
Accessories and
F9 Glow Plugs 50 F22 25 J Front Lights R
Front Horn
Cab Accessories
F11 Bobcat Controller 25 F24 25 L Not Used --
Power Port
Auxiliary
F13 25 F26 Not Used --
Controller
Figure 245
NA3312
The table below is for later models with decal part number 7279963. Fuse location and amperage ratings are shown
in the table below and on the decal [Figure 245]. Relays are identified by the letter “R” in the AMP column.
ITEM ICON DESCRIPTION AMP ITEM ICON DESCRIPTION AMP ITEM ICON DESCRIPTION AMP
Cab Switched
F1 Rear Lights 15 F14 5 A Switched Power R
Power
Drive Controller
F4 Heater / HVAC 25 F17 25 D Traction R
Back-up Alarm
Switched Power
F5 25 F18 Attachments 25 E Rear Lights R
Back-up Alarm
Cab Switched
F8 25 F21 Engine Controller 15 H Not Used --
Power
Accessories and
F9 Glow Plugs 50 F22 25 J Not Used --
Front Horn
Cab Accessories
F11 Bobcat Controller 25 F24 25 L Not Used --
Power Port
Auxiliary
F13 25 F26 Not Used --
Controller
Figure 246
NA3327
The table below is for later models with decal part number 7300643. Fuse location and amperage ratings are shown
in the table below and on the decal [Figure 246]. Relays are identified by the letter “R” in the AMP column.
ITEM ICON DESCRIPTION AMP ITEM ICON DESCRIPTION AMP ITEM ICON DESCRIPTION AMP
Cab Switched
F1 Rear Lights 15 F14 5 A Switched Power R
Power
Drive Controller
F4 Heater / HVAC 25 F17 25 D Traction R
Back-up Alarm
Switched Power
F5 25 F18 Attachments 25 E Rear Lights R
Back-up Alarm
Cab Switched
F8 25 F21 Engine Controller 15 H Not Used --
Power
Accessories and
F9 Glow Plugs 50 F22 25 J Not Used --
Front Horn
Auxiliary
F13 25 F26 Not Used --
Controller
Figure 247
NA3345
The table below is for later models with decal part number 7323429. Fuse location and amperage ratings are shown
in the table below and on the decal [Figure 247]. Relays are identified by the letter “R” in the AMP column.
ITEM ICON DESCRIPTION AMP ITEM ICON DESCRIPTION AMP ITEM ICON DESCRIPTION AMP
Cab Switched
F1 Rear Lights 15 F14 5 A Switched Power R
Power
Drive Controller
F4 Heater / HVAC 25 F17 25 D Traction R
Back-up Alarm
Switched Power
F5 25 F18 Attachments 25 E Rear Lights R
Back-up Alarm
Cab Switched
F8 25 F21 Engine Controller 15 H Not Used --
Power
Accessories and
F9 Glow Plugs 50 F22 25 J Not Used --
Front Horn
Auxiliary
F13 25 F26 Not Used --
Controller
Figure 248
NA3424
The table below is for later models with decal part number 7356066. Fuse location and amperage ratings are shown
in the table below and on the decal [Figure 248]. Relays are identified by the letter “R” in the AMP column.
ITEM ICON DESCRIPTION AMP ITEM ICON DESCRIPTION AMP ITEM ICON DESCRIPTION AMP
Cab Switched
F1 Rear Lights 15 F14 10 A Switched Power R
Power
Drive Controller
F4 Heater / HVAC 25 F17 25 D Traction R
Back-up Alarm
Switched Power
F5 25 F18 Attachments 25 E Rear Lights R
Back-up Alarm
Cab Switched
F8 25 F21 Engine Controller 15 H Not Used --
Power
Accessories and
F9 Glow Plugs 50 F22 25 J Not Used --
Front Horn
Auxiliary
F13 25 F26 Not Used --
Controller