Professional Documents
Culture Documents
PERLIS
FACULTY ARCHITECTURE, PLANNING AND SURVEYING
DEPARTMENT OF SURVEYING SCIENCE AND GEOMATICS
BACHELOR OF SCIENCE AND GEOMATICS – AP220
LAB EXERCISE 2
SEMESTER 5
GROUP RAP2205C
TABLE OF CONTENTS
CONTENTS PAGES
1.0 INTRODUCTION
2.0 METHOD/PROCEDURE
3.0 RESULT
1.0 INTRODUCTION
1
A critical step in the field of photogrammetry is ground control point (GCP)
survey, which entails precisely locating and noting the coordinates of GCPs on the
ground. These coordinates are then used to georeferenced and create precise 3D models
and maps from aerial photography. GCPs are actual objects that are positioned on the
ground to act as benchmarks for the photogrammetry software to precisely align and
scale the photos. The precise measurement of each GCP's coordinates requires the use of
cutting-edge surveying tools, such as total stations or GPS receivers.
To make sure the GCPs are appropriately positioned and their coordinates are
documented, the GCP survey is normally carried out before the aerial survey. To
precisely measure the GCPs, the surveyors often combine a variety of surveying
methods, such as measuring the angles and distances between the GCPs, utilising a total
station, or capturing their locations using GPS. After precisely georeferencing the aerial
images with the recorded coordinates, photogrammetry software is used to analyse the
data and create accurate 3D models, topographic maps, or orthophotos.
The calibre and accuracy of the GCP survey have a significant impact on the
photogrammetry output accuracy. As a result, it is crucial that the survey be conducted
by qualified experts using top-notch surveying tools. In order for the photogrammetry
programme to give reliable results, the surveyors must also make sure that the GCPs are
discernible and simple to identify.
2
2.0 METHOD / PROCEDURE
i. Open PHOTOMOD and input the project name. Choose the central projection and select
the Cartesan Right Projection.
3
iii. Go to block layout and click w/o layout to split the overlapped image for the actual
image arrangement.
4
v. Pin/Click at the same features or location that will be overlapped on each picture.
vi. Click insert on the next picture to create the line. Click on the line if we want to delete it.
vii. Go to block layout and choose by ties then click apply to joint to line into the selected
points.
5
3.0 RESULT
6
7
4.0 DISCUSSION & CONCLUSION
GCPs are actual ground-based points of reference that have been surveyed and
marked with precise coordinates. Following that, the photogrammetric method uses these
points as a point of reference, allowing for the alignment and scaling of the photos as
well as the creation of high-quality 3D models, maps, and measurements. Without GCPs,
a variety of issues, such as camera calibration, atmospheric distortion, and picture
distortion brought on by terrain relief, can have an impact on photogrammetric results.
The success of the GCP survey also depends on choosing the right control points.
Using high-precision surveying tools like total stations or GPS receivers, the chosen
spots should be clearly visible in the photos and have their coordinates precisely
determined. For repeatability and traceability, the measurements should also be
accurately documented.
8
9