Professional Documents
Culture Documents
Section -2 and 4
Use S355 grade steel
1. Design an unrestrained cantilever beam for a span of 2.0m. Design load acting on
the beam is uniformly distributed load of 50 KN/m and point load at free end 20KN.
2. Design a restrained beam for a span of 7m. Design load acting on the beam for three-
point loads of 50 KN/m each at equal distance and with uniform distributed load of
25 KN/m.
3. Design the simply supported beam using Single Channel section for a span of 6.0
m. The beam is loaded with designed for uniformly distributed dead load of 60kNm
and imposed load of 70 KNm.
4. The purlin has to be designed as a simply supported beam using tube section for a
span of 5.0 m. The beam is loaded with designed for uniformly distributed dead load
of 20kNm and imposed load of 1.5 KN at midspan.
5. The purlin has to be designed as an oven hang beam using tube section for a span
of 5.0 m which is simply supported at the ends and overhang length of 1m. The
beam is loaded with designed for uniformly distributed dead load of 20kNm for the
full length of the beam.