Professional Documents
Culture Documents
LATHEE TOP MO
OUNT REEVERSE TU
UMBLER
J. Taylor
1
2
Steel plate with clutch p
pulley mounte ed had to be ttrimmed backk to clear tum
mbler plate. O One of the bo
olts
used to mo ount the steel plate interfe
ered with the reverse gear Visible in nexxt picture.
Plastic Forw
ward gear & 445T reverse ge ear both bore
ed and had baall bearings p
pressed in.
Steel plate could not be trimmed eno
ough to comppletely clear t he tumbler p
plate because to the locatio
on of
the mounting bolt. Bolt was counterssunk and tum
mbler plate ha d about ¼ incch milled back to clear.
3
Tumbler in forward position.
The bolt mo ounted in the
e curved slot hhas nylon busshings on fronnt & back of tthe aluminumm tumbler plaate.
There is also a brass spacer, over the bolt & betwe een the nylonn spacers to aallow the boltt to be tighten
ned
down witho out binding thhe plate. The
e original shee
et metal piecee that is bolteed on was cutt out to proviide
clearance foor the back bushing. The bbolts used to mount the shheet metal pieece were also o replaced wiith
button heads for clearan nce.
Tumbler in reverse posittion.
4
5
To mark the he detents, evverything wass assembled, tthe gears were properly spaced and the
e holes for th
spring loaded plunger wwas snapped in n each locatio
on to mark thhe proper hole, then disasssembled and
drilled.
6
7