Professional Documents
Culture Documents
萬向頭
GY-C50
VERTICAL
MULTIANGULAR MILLING
HEAD ATTACHMENT
使用說明書
USE EXPLANATION
功陽精機股份有限公司
GONG YANG MACHINERY CO., LTD.
台中縣太平市富宜路 190 巷 19 號
No.19 LANE 190, FUYIH RD., TAIPING,
TAICHUNG, TAIWAN
CABLE: GONG YANG TAICHUNG
TEL:886-4-22781321 FAX:886-4-22701379
E-mail:gongyang@ms23.hinet.net
CONTENTS
1. GENERAL PRINCIPLES…………………………………………….. 1
4. LUBRICANT OIL…………………………………………………….. 4
(1) Could change machine to make vertical milling and cross milling and any
angle.
(2) Fit a spiral bevel gear, the machine more precise and wear resistant.
machine tools.
(4) Loosen “T” screw to make 360° adjusting and choice the direction of
(5) Suitable to planer for boring, cutting top face and bevel face trim.
(6) Gear and spindle are made of chromium molybdic acid alloy steel, through
Attention :
(1) In order to keeps the spindle bearing and gear to lubricate if the angular
milling head haven’t use more than tree month form deliver date or stop use
more than tree month. Please accoring to keep milling head as following:
(a) Before the connect milling head, please turn upon the spindle more than
5 times. That in order to make bearing and gear moislen lubricant oil.
-1-
2. OUTSIDE SIZE
-2-
3. PAR CHART OF MACHINE
head.
(2) The quantity in the covering shell should be between 300gm and
400gm.
(3) In the normal used, every used 8-10 hours. Please given grease, every once
-4-
5. HOW TO AFJUSTING FOR SPINDLE
BEARING
CONDITION: when finding to cutter will be off and on or spindle are loosen.
1.open the rear cover. Ref. Fig4-(1).
4.tast spiral spindle. Not too lock or loosen. If too lock will be thermogenetic
and sinter will be to affect the efficiency.
5.after afjust properly, lock the fixing screw. Ref. Fig4-(2)
-5-
6.CONNECTS’ MULTIANGULAR MILLING -
- HEAD
(Example by standard Multiangular milling hand )
front-cover.
3.Together graduated dial with milling head and notice that adjustments’ zero
point.
4.In order to make bearing and gear moisten lubricant oil. Please to turn upon
5.Fixed the Multiangular milling head above the graduated dail then locking “T”
screw.
6. Test: fit a percentage chart to the spindles’ toper and diameter of Multiangular
-6-
-3