Professional Documents
Culture Documents
Submitted by:
Karimullah
Reg No: 21PWELE5844
Section: A
Submitted to:
Sir Farooq
May,7, 2023
Department of Electrical Engineering
University of Engineering and Technology, Peshawar
Lab No 06
Title:
To Study the Transient Response of RC Series Circuit
Introduction:
In this lab we will practically analyze the transient behavior of RC series circuit using
Simulink and form the equations of the corresponding graphs using curve fitting tool.
Methodology:
Open a blank model in Simulink and make the circuit as shown above.
Make the circuit as shown in the above diagram.
In capacitor set the initial capacitor voltage to zero.
Also here the Time period (t=RC) is 1msec so set the time to 10 m sec(0.01) to get 10
time periods of graph.
Use scope to verify your graphs before sending it to workspace for analysis using simout.
Here we have both R=100 ohm and C=10uF.
The applied DC source is 12V.
To measure voltage connect it in parallel and current in series.
Add the power gui from library
To see the results double click on Scope.
Results:
Hence we get the following Results.
The equations generated by curve fitting tool are as follows:
Current Equation:
Voltage Equation:
Conclusion:
Hence Simulink is proven to be a powerful and easy tool for simulation and transient
analysis of RC series circuit. More over it is efficient and time saving.