Professional Documents
Culture Documents
Where To Set Sensor and Vibrator
Where To Set Sensor and Vibrator
2.Plate-type workpiece(length is approximate with width,and length is 5 times than the thickness),the
rubber pads(4 pieces) are put on the point of 1/3 length from the end,the vibrator is put on the middle
or one end of one side,the sensor is put on the other end.
3.Square-type workpiece(the length,width and thinckness are approximate),two of them are put on
one side on the point of 1/3 length from the end,another is put on the middle of the other side,the
vibrator is put on the middle of side which only has one pad,the sensor is put on the othe end.this
type workpiece need 3 pads.
4.Round-type workpiece,the rubber pads(3 pieces) are put on the roundness averagely,the vibrator is
put on the middle of two pads,the sensor is put on the middle of the others two ones.
7.Large workpiece with heavy rigidity,it can be vibrated by certain rotating speed and tiem.
Result identify
There are two ways to identify if has obtained good result,one is the peak of curve
after vibrating is higher than the peak of curve before vibrating;the other is the
curve after vibrating on the left of curve before vibrating.
Of course,there is a word “ok” or “error” on the bottom of the printing paper,if “ok”
means good result,if “error” means not good result.then adjust it and vibrate again.