Professional Documents
Culture Documents
eeds Infant
Nursing Skills and
lator
INSTRUCTION MANUAL
way Management Trainer
d
e Child CRiSis™ Manikin
HEALTHCARE
hild CRiSis™ Manikin
ythmia Tutor Micro-Preemie
date Kit
way Management
th Stand
aosseous
Micro-Preemie
LF01280 & LF01281
Femoral Access Leg
way Management LF01280U & LF01281U
orso
e Infant CRiSis™ Manikin
dy® CPR Manikin
INSTRUCTION MANUAL
mpt® Adult/Child Manikin
mpt® Infant Manikin
LF00908U
ealthcare.com
@enasco.com
800.431.4310
anesville Ave.
on, WI 53538
10/9/18 3:09 PM
About the Simulator
This page
A.
M. N.
C.
H.
E.
This page is
A. K.
D. M. N. J.
C.
H.
E. G.
L. K. F.
I. B.
D. J.
Figure 1 Figure 2
SETUP
A. INSTALLING THE REPLACEABLE AIRWAY
1. Remove the installed lung block, if applicable, from the baby’s chest. (See figure 1.)
2. Thoroughly lubricate all of the outside surfaces of the airway and around the baby’s mouth.
3. Gently insert your lubricated finger into the airway
Figure 1
over
Figure 2 the tongue and epiglottis.
4. Push the tube end of the airway into the baby’s lubricated mouth. (See figure 2.)
SETUP SETUP
5. Work your fingers around the inside of the mouth, freeing the baby’s lips. Be sure the airway is fully
installed. THE REPLACEABLE AIRWAY
A. INSTALLING
1.2 Remove the installed lung block, if applicable, from the baby’s chest. (See figure 1.)
A. INSTALLING THE lubricate
2. Thoroughly REPLACEABLE AIRWAY
all of the outside surfaces of the airway and around the baby’s mouth.
3. Gently insert your lubricated finger into the airway over the tongue and epiglottis.
1. Remove
4. Pushthe installed
the tube lung
end of the airway block,
into the if applicable,
baby’s lubricated from
mouth. (See figure 2.) the baby’s chest.
(See 5.Figure
Work your1.)
HC18000028INM32.indd 3-4
fingers around the inside of the mouth, freeing the baby’s lips. Be sure the airway is fully
2. Thoroughly installed. lubricate all of the outside surfaces of the airway and around
2
the baby’s mouth.
3. Gently insert your lubricated finger into the airway over the tongue and
epiglottis.
4. Push the tube3-4end of the airway into the baby’s lubricated mouth.
HC18000028INM32.indd
2
Set Up
B. LUNG BLOCKS
B. LUNG BLOCKS 1. Two different lung blocks have been pro-
Figure 3
10/9/18 3:09 PM
UMBILICUS
The reservoir can be used to either draw or receive fluids. Maximum capacity is
approximately
UMBILICUS 5 cc. Do not overfill. Always use plain water, with or without the
blood
Thepowder
reservoir canprovided. (Caution:
be used to either Bloodfluids.
draw or receive mixture
Maximum will stainisskin
capacity 5 cc. (See
and fabric.)
approximately
Figures
Do not4overfill.
& 5.)Always
Alwaysuse flush andwith
plain water, drain the the
or without system thoroughly
blood powder provided.and store with the
plug(Caution:
hole openBlood so thewill
mixture reservoir canfabric.)
stain skin and dry. (See figures 4 & 5.) Always flush and drain the system 3
thoroughly and store with the plug hole open so the reservoir can dry.
3
Set Up
IV SITES
The Micro-Preemie has four molded-in sites typically used for peripheral IV
access: right scalp, right foot, left arm, and left hand. All four will accept an
infusion device, but none of the sites are functional.
Note: The soft material of this manikin is self- healing and will accept a small
gauge needle anywhere on the body. Before insertion, make certain that the
needle will not damage any underlying structures.
IV SITES OTHER
Over time,
The repeated punctures,
Micro-Preemie has four molded-inespecially
sites typically usedinfor
the same
peripheral area,right
IV access: will result
scalp, in damage
right foot, Various monitors and sensors ma
to the simulator. Nasco
left arm, and left hand. AllHealthcare
four will accept anwarranty
infusion device,does not
but none cover
of the sites aredamage
functional. caused by infant.
needle insertion.
Note: The soft material of this manikin is self- healing and will accept a small gauge needle anywhere
on the body. Before insertion, make certain that the needle will not damage any underlying structures. CARE OF THE SIMULATOR
Over time, repeated punctures, especially in the same area, will result in damage to the simulator. Nasco • Nasco Micro-Preemie mater
warranty does not cover damage caused by needle insertion.
CHEST TUBE • While the arms and legs are
CHEST TUBE • The manikin is completely im
A permanent site in the baby’s right side will accept a nonfunctioning 8-10 FR if soiled.
A permanent site in the baby’s right side will accept a nonfunctioning 8-10 FR chest tube for placement
chest tube forpractice.
and care placement and care practice. • Always allow all component
• Baby powder can be applied
Figure 6
AVAILABLE SUPPLIES/REPLAC
LF01206(A)U Consumables
LF01211U Micro-Preemie
LF01282U Bilateral Chest
LF01283U Unilateral Che
LF01284U Airway Micro-
LF01285U Micro-Preemie
LF01286U Bilateral Chest
Figure 7 LF01287U Unilateral Che
LF01288U Stoma (light),
PRESSURE ULCERS
PRESSURE ULCERS LF01289U Stoma (dark),
The manikin shows
The manikin showsseveral typical
several typical sites
sites of skin of skin
breakdown: breakdown:
occiput occiput
and heels. (See figures 6 & 7.) and heels. LF03461U Small, Soft Ca
(See Figures 6 & 7.) SB51833U Bulb Syringe, 2
Figure 8 Figure 9
BIRTH DEFECTS
BIRTH DEFECTS
A. Omphalocele
A. Omphalocele
The umbilicus may be replaced with the omphalocele for specialized training. Ensure the abdominal
The umbilicus
reservoir ismay
empty. be replacedis nonfunctional.
The omphalocele with the omphalocele
(See figure 8.) for specialized
training. Ensure the abdominal
B. Myelomeningocele reservoir is empty. The omphalocele
(Neural Tube Defect)
is nonfunctional. (See Figure
The optional structure 8.) into the small opening in the back of the Micro-Preemie.
may be plugged
B. Myelomeningocele
(See figure 9.) (Neural Tube Defect) The optional structure may
be plugged into the small opening in the back of the Micro-Preemie.
(See Figure 9.) may vary slightly from photo. Nasco reserves the right to change product color, materials,
Actual product
supplies, or function as needed.
4
4
HC18000028INM32.indd 7-8
OTHER
Various monitors and sensors may be connected to the Micro-Preemie just as
they would be to a real infant.
5
B. LUNG BLOCKS
1. Two different lung blocks ha
vided: a normal block simula
expansion of the lungs, and
simulating a collapsed right
blocks can be identified by t
diagram on the back.
2. To install either lung block, e
airway is installed (See “A. In
Nonfunctional Replaceable Airway” for mor
Scalp Vein Site 3. Apply a small amount of lub
short tubing section of the a
NG Access with
5 cc FR NG Tube 4. Insert the lubricated tubing
5. Fit the lung block into the ch
ET Access with C. PATENT UMBILICUS
#0 Miller and The umbilical stump has one func
2.5 mm ET Tube within the abdomen.
D. OSTOMY
Lung Cavity The nonfunctional stoma can be
GENERAL INSTRUCTIONS FO
AIRWAY AND VENTILATION
Nonfunctional The baby will accept a functionin
Vein Sites The lubricated tube must be plac
fluids through the mouth. BVM ca
GI
Chest Tube The left nostril will accept a 5 Fr n
Umbilical tube will enter an embedded tube
Reservoir Note: Fluid administration is not
embedded tube is approximately
Stoma when training is complete.
Figure 4
Nonfunctional
Vein
UMBILICUS
The reservoir can be used to eithe
Do not overfill. Always use plain w
(Caution: Blood mixture will stai
thoroughly and store with the plu
HC18000028INM32.indd 5-6
6
7
Nasco Healthcare
16 Simulaids Drive
Saugerties, NY 12477
1-833-NASCOHC (627-2642)
info@nascohealthcare.com
www.nascohealthcare.com