Professional Documents
Culture Documents
INSTRUCTIONS
STEICOsill timber
Sealing system for window sills
1 2
Applying the diffusion-open STEICO underlay STEICOmulti UDB The windows are installed on the underlay. Before installing insert space
as temporary weather protection until window installation between STEICOfix and cut the underlay back trapezoidally (see picture 5)
Form corners
see step 4
Fold narrow separating paper Fold adhesive strip together Fold the glued inner corner
to the front in the middle to the side
Then apply the STEICOmulti tape F 20/40 mm adhesive strips to the insu- To form the corners, the adhesive strips are cut to length twice the width
lating wedge in such a way that a three-sided "trough" is formed of the insulation wedge. Then follow the steps described above
5 6
As a bedding material for the insulating wedge apply STEICOmulti fill Installation of the STEICOfix insulating wedge: TIP: Fold back the separating
adhesive beads, e ≤ 300 mm paper, for easy removal later
7 8
Insert the STEICOfix insulating wedge into the recess, remove the remaining For secure render connection underneath the STEICOfix insulating wedge,
separating paper and press the STEICOmulti tape F 20 / 40 mm into place install a parapet profile (stainless steel screws or staples)
The protruding flap of the laminated underlay is bonded to the drip edge Application of STEICOmulti fill adhesive beads e ≤ 30 cm for elastic fixing of
of the parapet profile using STEICOmulti fill the window sill
Window sill installation. TIP: The rear bead is located in the matching window Construction and assembly of the reveal board. Driving rain protection is
groove, the front one has a distance of ≥ 30 mm to the render facade achieved by attaching joint sealing tapes along the back edge and short edges
13 14
Application of STEICOmulti fill adhesive beads into the timber frame Inserting the reveal board flush with the outer edge of the ETICS facade
construction to ensure a secure connection for the reveal board TIP: Allow for possible window frame extension
15 16 FI
QuiN I
ck aSHED
Version dated 08/2020 | The current edition applies. Errors reserved.
nd e !
asy
Fixing of the reveal board with pressure for undisturbed curing of Installation of a suitable rendering strip for safe rendering and continuation
STEICOmulti fill by means of wide back staples or stainless steel screws of the ETICS work