Professional Documents
Culture Documents
Transportation Instruction F-Series 9852 1405 01c
Transportation Instruction F-Series 9852 1405 01c
code
Transport Instruction ROC
2004-01
ROC F6, F7, F9
1. Turn the battery switch ON 7.Move the levers (7) in the same direction as
you want to go. Check track tilting, adjust
switches (8) if needed (See item 9) point 9.
7
6 a
d b e
5
B
3
6. Position the boom and feedbeam with
12. Turn the battery switch OFF.
levers (6).
IMPORTANT!
6
A B A B
Folding boom version: Single boom version:
For best rig stability, For best rig stability,
position boom, feed and position boom, feed and
rock drill as follows:
- Boom cylinder max. OUT.
! rock drill as follows:
- Rock drill in END (upper)
- Boom extension cylinder max. IN. position.
- Feed dump cylinder max. OUT. - Operate the boom and
(Make sure that feed does not hit feed controls to lay down
the lifting eq.) the feed on the feed
Rock drill in END (Bottom) position. support. (Make sure that
the body does not get
damaged.
Both versions:
Check that the jack is retracted. Make sure that the oscillation cylinders are LOCKED
see item 8.
Fasten the sling under the tracks at A and B shown above. Check that none of the hoses,
controls or other parts are damaged when the slings become tightened.
Transportation
- Run the rockdrill to it´s lowest position
- Alternately use the boom and feed controls to lay down the
feed on to the transportation vehicle.
After stopping the rig on the transportation vehicle: Single boom Alt. 1
- Run down the hydraulic jack
- Lock the oscillation cylinders, see item 8.
- Shut down the diesel engine and switch off the battery switch
- Lash the rig on the transport vehicle