Professional Documents
Culture Documents
Tank Information:
EQUIPMENT TAG:
Location:
Date of Inspection:
Inspection Process:
1. Prepare. Clean the part by spraying SKC-S onto the surface. Next, wipe the part dry with a clean cloth.
2. Penetrant . Apply the penetrant to the test area. Allow the penetrant to dwell for 10-30 minutes. Then,
remove the excess penetrant by wiping the part down using a clean dry cloth. The dwell recommended time
specified by the manufacturer was followed.
3. Developer. Apply the developer to the test area. Allow the developer to dwell for 10-60 minutes.
A inspection pictures was generated, documenting the location, size, and nature of any observed
indications, as well as any recommended actions, if any.
This certification confirms that the Dye Penetrant Inspection was conducted diligently and in accordance
with the specified procedures. The inspection results are valid as of the date mentioned above.
page 1 of 1